Insp Adj - Yamaha VX700F Manuel D'atelier

Item
Check operation and fluid leakage.
Brake and parking brake Adjust free play and/or replace pads if necessary.
Replace brake fluid.
Check oil level.
Drive chain oil
Replace.
Check deflection.
Drive chain
Adjust if necessary.
Check for wear and damage.
Skis and ski runners
Replace if necessary.
Check operation.
Steering system
Adjust toe-out if necessary.
Check for damage.
Strap (MM700)
Replace if necessary.
Check operation.
Lights
Replace bulbs if necessary.
Check fluid level.
Add only distilled water if necessary.
Battery
(VX700DX/VT700)
Check specific gravity and breather hose operation.
Charge/correct if necessary.
Check engagement and shift speed.
Adjust if necessary.
Inspect sheaves for wear/damage.
Inspect weights/rollers and bushings for wear-
Primary and secondary
for primary.
clutches
Inspect ramp shoes/bushings for wear-for sec-
ondary.
Replace if necessary.
Lubricate with specified grease.
Steering column bearing
Lubricate with specified grease.
Ski and front suspension Lubricate with specified grease.
Suspension component Lubricate with specified grease.
Parking brake cable end Lubricate with specified grease.
and lever end/throttle cable
Check cable damage.
end
Replace if necessary.
Make sure that the shroud latches are hooked.
Shroud latches
Check tightness.
Fittings and fasteners
Repair if necessary.
Tool kit and recommended
Check proper placement.
equipment
NOTE:
Brake fluid replacement:
1. When disassembling the master cylinder or caliper cylinder, replace the brake fluid. Normally check the brake
fluid level and add the fluid as required.
2. On the inner parts of the master cylinder and caliper cylinder, replace the oil seals every two years.
3. Replace the brake hoses every four years, or if cracked or damaged.
PERIODIC MAINTENANCE TABLE
Remarks
2-2
INSP
ADJ
Initial
Pre- 1 month
operation or
check 800 km
(Daily) (500 mi)
(40 hr)
See NOTE.
Initial at 500 km (300 mi) and every 800 km
(500 mi) thereafter.
Whenever operating elevation is changed.
Every
Seasonally
or
3,200 km
(2,000 mi)
(160 hr)
2