Maintenance Diagram General; Periodic Maintenance; Checking Oil Level And Changing Pump Oil - Dibo JMB-S Mode D'emploi

E N
M A I N T E N A N C E
MAINTENANCE DIAGRAM
1 General
Check daily by means of the maintenance diagram the high pressure cleaner.
You find the maintenance diagram on the following pages.
Check even all transmission belts on good tension and possible defects.
If this case is not, then best consult the proper maintenance technicians.
PAY ATTENTION: Take care that the transmission belts are not in
movement and observe the applying safety standards! Always secure
the trailer with wheel blocks before starting any maintenance works!
2

Periodic maintenance

DESCRIPTION
Check the electric cables, high &
low pressure hoses, couplings and
control of the oil level. Check the
wheel bolts/ Ball clutch/plug/lights/
brake lines/good tyre pressure of the
trailer.
Refreshing pump oil.
Refreshing reduction gearbox oil.
Cleaning water filter(s).
Replacement and cleaning oil filters
and fuel filters.
Cleaning fuel tank.
Change the alternator belt.
• All following refreshments of pump
oil and reduction gearbox oil.
• Cleaning of the heat exchanger (de-
pending fluid properties and calcium
deposits).
• Replace the bypass valve(s).
Refreshing engine oil.
Extra control/replacement of joints,
valves, o- rings by acknowledged
DiBOtechnicians!
• Lubricate or oil all sliding or jointed
parts of the overrun device
• Check on possible wear of the
wheel brakes/ bearings/brake lining.
• Replace the coolant of the engine.
3

Checking oil level and changing pump oil

Check for each use of the machine, the oil with the oil level glass or with the oil
level bar. Oil must stand right with the sign of the oil level glass, if this is not, oil
tops up until the sign. If oil looks milky, consult directly the DiBO technicians.
To refresh oil, work as follows:
• Unbolt the drain plug below the pump.
• Unbolt the tap with the oil level bar.
• Catch all oil in a barge and remove oil like further described in the guide.
• Force up the drain plug there and top up the oil in the breach to the upper part
to on the mark line.
• Force up the tap with the oil level bar there.
• Recommended oil: 1.836.042 (+- 1 liters / 0.26 Gallon, depending the pump).
DiBO 34
PERIOD
After each use.
First 50 hours.
First 50 hours.
First 50 hours.
First 50 uur, elke volgende
250 hours.
First 50 uur, every next
250 hours.
Every 500 hours. Yearly.
Every 250 hours.
See enclosed motor instruction
manual.
Every 750 hours.
Yearly