Operation; Setup - Titan PowrLiner 2850 Mode D'emploi

OPERATION

4
OPERATION
This equipment produces a fluid stream at
extremely high pressure. Read and understand
the warnings in the Safety Precautions section
at the front of this manual before operating this
equipment.
4.1

SETUP

The PL2850 comes in two versions, a one-gun
i
version and a two-gun version. All information
given in this manual applies to both units, except
where noted.
1. Ensure that the siphon hose and the return hose are
attached and secure.
2. Make sure the pump ON/OFF switch (1) is in the OFF
position.
3. Turn the pressure control knob (Fig. 4, item 2) fully
counterclockwise to its lowest pressure setting.
1
4. Fill the fluid section oil cup with approximately one
tablespoon of piston seal lubricant (Piston Lube).
Never operate unit for more than ten seconds
without fluid. Operating this unit without fluid
will cause unnecessary wear to the packings.
Attention
5. Check the engine oil level. The gasoline engine oil level
is determined by the manufacturer. Refer to the engine
manufacturer's service manual (supplied).
6. Close the fuel shut-off lever and fill the gas tank with
gasoline. Use only high quality, unleaded gasoline.
12
ONE GUN SETUP
1. Using a wrench, thread the 50' airless spray hose to the
outlet fitting on the sprayer. Tighten securely.
2. Attach an airless spray gun to the spray hose. Using two
wrenches (one on the gun and one on the hose), tighten
securely.
TWO-GUN SETUP
1. Using a wrench, thread the valve assembly (1) (with 50'
hose [2] attached) to the outlet fitting (3) on the sprayer.
Tighten securely.
2. Using a wrench, thread the 6' airless spray hose (4) to the
top outlet fitting on the valve assembly. Tighten securely.
4
1
2
2
3. Attach an airless spray gun to each of the spray hoses.
Using two wrenches (one on the gun and one on the
hose), tighten securely.
If you plan on using both guns, make sure the
i
valve handle is in the open position (handle is in
line with the 6' hose)
PL2850
3
Valve Valve
Valve Valve
closed open
closed open