Scheduled Maintenance Table; Machine Working Hour Check; Squeegee Cleaning - Nilfisk BR 601 Manuel D'utilisation

SCHEDULED MAINTENANCE TABLE

Procedure

Squeegee cleaning

Brush/cylindrical brush cleaning
Tank and vacuum grid with float cleaning
Battery charging
Squeegee blade check and replacement
Side skirt check
Solution filter cleaning
Battery (WET) fluid level check
Screw and nut tightening check
Check and adjustment of driving belts from motors to
cylindrical brushes
Squeegee cable sliding shoe lubrication
Electromagnetic brake efficiency check
Brush/pad-holder motor carbon brush check or
replacement
Vacuum system motor carbon brush check or
replacement
Drive system motor carbon brush check or
replacement
(1): After the first 8 working hours
(2): This maintenance procedure must be performed by an authorized Nilfisk-Advance Service Center

MACHINE WORKING HOUR CHECK

1. Insert the ignition key (12, Fig. B) and turn it to "I".
2. In the first 5 seconds of machine operation, the display
(8, Fig. B) shows the total number of working hours
(scrubbing/drying) performed by the machine.
Turn the ignition key (12, Fig. B) to "0".
909 6160 000(2)2006-10 A
Daily or after using
Weekly
the machine
SQUEEGEE CLEANING
1. Drive the machine on a level floor.
2. Insert the ignition key (12, Fig. B) and turn it to "I".
3. Lower the squeegee (12, Fig. C) by pressing the switch
(6, Fig. B).
4. Turn the ignition key (12, Fig. B) to "0".
5. Disconnect the vacuum hose (11, Fig. C) from the
squeegee.
6. Loosen the handwheels (15, Fig. C) and remove the
squeegee (12).
7. Wash and clean the squeegee. In particular, clean the
compartments (1, Fig. F) and the hole (2) from dirt and
debris. Check the front blade (3) and the rear blade (4)
for integrity, cuts and tears; otherwise replace them.
8. Assemble in the reverse order of disassembly.
USER MANUAL
Every six months
(1)
(2)
(2)
(2)
NOTE
The squeegee must be clean and its blades
must be in good conditions in order to get a
good drying.
CAUTION!
It is advisable to wear protective gloves when
cleaning the squeegee because there may be
sharp debris.
Yearly
(2)
(2)
(2)
15