§2.12 - Platform
Platform construction
Articulation points
Articulation pins
Roll-stops at rear end of platform
Safety rails
Bridge plate at front end of platform
Platform lights / flags
О Visibility of the platform in public traffic
Synthetic platform rollers or protection surfaces
Platform at loading floor
Extendable platforms (+ sliding section)
§2.13 - Test of emergency functions
Emergency function slide-in / slide-out (EMR button on power pack)
Emergency function lift / up
Emergency function lower / down
Emergency function roll-stop down
Audible alarm
DHOLLANDIA
EN
What to verify? Execute, service or repair if required !!
•
General condition, condition of the welds
•
Check for cracks & deformation.
Corrosion
•
•
General condition, check for cracks, deformation, elliptic deformation
•
Locking of the articulation pins by locking pins, bolts & nuts
•
Greasing / lubrication
General condition, function & operation
•
•
Positive locking in vertical position, the device is safe to use
•
The hydraulic cylinder of the roll-stop is free from oil leaks
•
General condition, function & operation
Re-adjust the operating mechanism if required
•
•
General condition, function & operation, routing & guidance of the electrical cables from the plat-
form over the lift arms to the connection point in the power pack
The platform is clearly visible in surrounding traffic from all approachable angles
•
•
General condition, replace when damaged or worn out
•
Alignment of the platform flush with the loading floor
•
General condition, function & operation of the sliding-in / sliding-out of the moveable platform
part.
What to verify? Execute, service or repair if required !!
•
The platform is blocked when the EMR button is not activated.
•
The platform can be pulled out / pushed in when the EMR button is activated.
•
General condition, function & operation of the hand pump in the power pack
General condition, function & operation of the descend valve in the power pack, and the manual
•
operation of this valve
•
General condition, function & operation of the electrovalve of the roll-stop cylinder on the lift
frame, and the manual operation of this valve.
Alarm signal is clearly audible during all functions
•
B26
Freq.
M3 J1
M3 J1
M3 J1
M3 J1
M3 J1
STE
M3 J1
M3 J1
M3 J1
Freq.
M3 J1
M3 J1
M3 J1
M3 J1