Publicité
OUTLET WATER JACKET JOINT ................... 6-5
INSPECTION .............................................. 6-6
INSTALLATION ......................................... 6-7
CHAPTER 7.
CARBURETION
CARBURETORS ............................................... 7-1
INSPECTION .............................................. 7-5
ASSEMBLY ................................................ 7-6
FUEL LEVEL ADJUSTMENT ..................... 7-8
THROTTLE POSITION SENSOR (TPS)
INSPECTION AND ADJUSTMENT ........... 7-9
INSTALLATION ....................................... 7-11
FUEL PUMP .................................................... 7-12
INSPECTION ............................................ 7-13
INSTALLATION ....................................... 7-13
CHAPTER 8.
ELECTRICAL
SWITCH INSPECTION ..................................... 8-1
SWITCH INSPECTION ............................... 8-1
INSPECTING A SWITCH SHOWN IN
THE MANUAL ........................................... 8-1
IGNITION SYSTEM .......................................... 8-2
CIRCUIT DIAGRAM ................................... 8-2
TROUBLESHOOTING ............................... 8-3
SPARK PLUG CAP ..................................... 8-4
IGNITION COIL .......................................... 8-4
AC MAGNETO ........................................... 8-4
SPARK PLUG ............................................. 8-5
THROTTLE OVERRIDE SYSTEM
(T.O.R.S.) ................................................... 8-5
HANDLEBAR SWITCH (RIGHT) ................ 8-6
CARBURETOR SWITCH ............................ 8-6
MAIN SWITCH ........................................... 8-7
CONDENSER ............................................. 8-7
EMERGENCY ENGINE STARTING ........... 8-8
LIGHTING SYSTEM ......................................... 8-9
CIRCUIT DIAGRAM ................................... 8-9
TROUBLESHOOTING ............................. 8-10
BULB(S) ................................................... 8-11
HEADLIGHT BEAM SWITCH .................. 8-11
All manuals and user guides at all-guides.com
HEADLIGHT RELAY ................................ 8-12
LOAD CONTROL RELAY ......................... 8-12
SIGNAL SYSTEM ........................................... 8-13
CIRCUIT DIAGRAM ................................. 8-13
TROUBLESHOOTING ............................. 8-14
TAIL/BRAKE LIGHT BULB ....................... 8-17
BRAKE LIGHT SWITCH ........................... 8-17
WATER TEMPERATURE SENSOR ......... 8-18
OIL LEVEL SWITCH ................................. 8-19
FUEL SENDER ......................................... 8-19
GRIP WARMER SYSTEM .............................. 8-20
CIRCUIT DIAGRAM ................................. 8-20
TROUBLESHOOTING ............................. 8-21
GRIP AND THUMB WARMER COIL ....... 8-22
VARIABLE RESISTOR ............................. 8-22
YAMAHA POWER VALVE SYSTEM
(Y.P.V.S.) ........................................................ 8-23
CIRCUIT DIAGRAM ................................. 8-23
TROUBLESHOOTING ............................. 8-24
SERVOMOTOR ........................................ 8-25
FAULT LOCATION TABLE ............................. 8-26
CHAPTER 9.
SPECIFICATIONS
GENERAL SPECIFICATIONS ........................... 9-1
MAINTENANCE SPECIFICATIONS ................. 9-3
ENGINE ...................................................... 9-3
POWER TRAIN .......................................... 9-6
CHASSIS .................................................. 9-10
ELECTRICAL ............................................ 9-11
HIGH ALTITUDE SETTINGS ................... 9-13
TIGHTENING TORQUE ........................... 9-14
GENERAL TORQUE SPECIFICATIONS ......... 9-18
DEFINITION OF UNITS .................................. 9-18
CABLE ROUTING ........................................... 9-19
Publicité
