Troubleshooting; Troubleshooting Table - Invacare Robin Manuel D'utilisation

Invacare® Robin®

9 Troubleshooting

9.1 Troubleshooting Table

SYMPTOMS
Ceiling hoist does not respond to the
hand control's buttons and up/down
buttons on the ceiling hoist are not
responding.
Ceiling hoist does not respond to the hand
control's buttons, but up/down buttons
on the ceiling hoist are responding.
Lifting straps will only move down and
not up.
Lifting straps will only move up and not
down.
Ceiling hoist speed is the same with and
without load.
Lifting straps are twisted and do not
straighten out.
Ceiling hoist does not traverse the rails.
Ceiling hoist emits excessive noise when
activated.
Ceiling hoist will not charge
No indicator light on hoist
The emergency strap does not turn
ceiling hoist off
The emergency strap does not lower the
ceiling hoist.
18
PROBLEM
Emergency stop activated
System does not have power or battery
is discharged
Fuse is blown
Hand control not connected properly
Hand control defective
Battery nearly discharged
Load is too high
Hand control defective
Loose strap function activated
Non-load quick movement function
activated permanently
Lifting hooks do not turn freely enough
Straps are frayed
Rails require service or cleaning
Trolley worn or damaged (Robin® only)
Driving wheels worn or damaged (Robin®
Mover only)
Hand control defective (Robin® Mover
only)
Bearings, gearwheels or motor defective The hoist must be replaced. Contact an
System has no power
System has no power or battery is
discharged
Ceiling hoist requires service.
Ceiling hoist requires service.
SOLUTION
Check that the emergency stop is not
activated. Refer to 5.9 Resetting the
emergency stop or lowering feature, page
12.
Charge the battery or use emergency
battery. Refer to 5.5 Charging the
Battery, page 10.
The fuse needs to be replaced. Contact
an Invacare representative or specialized
dealer for service.
Check the hand control plug. Refer to 4.4
Inserting hand control plug, page 9 .
Replace the hand control.
Charge the battery or use emergency
battery. Refer to 5.5 Charging the
Battery, page 10.
Reduce the load. The hoist is equipped
with an over-current safety system.
Replace the hand control.
Contact an Invacare representative or
specialized dealer for service.
Contact an Invacare representative or
specialized dealer for service.
Clean or replace the hooks. Contact an
Invacare representative or specialized
dealer for service.
Contact an Invacare representative or
specialized dealer to replace the straps.
Contact an Invacare representative or
specialized dealer for service.
Trolley must be replaced. Contact an
Invacare representative or specialized
dealer for service.
Driving wheels must be adjusted. Contact
an Invacare representative or specialized
dealer for service.
Replace the hand control.
Invacare representative or specialized
dealer for service.
Check that the power supply is switched
on and connected to the charging station.
Contact an Invacare representative or
specialized dealer for service.
Check that the ceiling hoist has power
supply and that the battery is recharged.
Place the hand control in the charging
station and recharge the ceiling hoist.
Contact an Invacare representative or
specialized dealer for service.
Contact an Invacare representative or
specialized dealer for service.
1586745-E