Warranty Repair - Rock Shox 2000 JUDY RACE SL Manuel D'utilisation

Service • Warranty
must be facing the lower tube and the aluminum surface must face the shaft bolt.
18. Apply blue Loctite on steel shaft bolts and insert them into plunger assemblies. Use a 5mm hex wrench to
torque shaft bolts per "Torque Tightening Specifications."
19. Replace the oil in the fork by pouring the required amounts through the top of the upper tubes.
J J u u d d y y S S L L , , R R a a c c e e , , a a n n d d X X L L ( ( 6 6 3 3 / / 8 8 0 0 / / 1 1 0 0 0 0 m m m m ) ) : : standard volume is 120 cc's of RockShox Oil (4.0 oz.) per leg.
J J u u d d y y X X C C ( ( 6 6 3 3 / / 8 8 0 0 / / 1 1 0 0 0 0 m m m m ) ) : : standard volume is 130 cc's of RockShox Oil (4.4 oz.) per leg.
Important: Do not exceed these volumes. Too little oil will result in poor damping performance
and too much oil will result in reduced travel.
Note: Oil weight changes should be performed at this step.
20. Install spring assemblies in upper tubes. Grease top caps and begin threads by hand.
Note: Spring replacement should be performed at this step.
21. Torque top caps per Torque Tightening Specifications.
22. Refit the lubrication ring into the lower tube area.
23. Push the dust wipers onto the lower tube assembly.
24. Refit fork boot into XXX seal groove using a small blade screwdriver. Engage boot with XXX seal groove at the
rear and rotate boot around the upper tube to fully engage its lower edge behind the brace. Compressing the
boot and twisting as well as applying a small amount of oil on the mating surfaces helps.
25. J J u u d d y y S S L L , , R R a a c c e e , , a a n n d d X X L L o o n n l l y y : : Install adjuster knob into the lower bolt on the right leg, from a rider's
perspective. The knob may have to be rotated slightly. Once it is inserted, ensure that it fully engages the
bottom bolt and O-ring.
26. Re-install front wheel and reconnect the front brake cable according to the manufacturer's instructions.
Service
Judy forks should be fully serviced every year by a qualified technician with proper tools. Fore and aft movement
between the upper tubes and the lower tube assembly indicates that the bushings have worn and should be replaced.
Typically, bushings will need to be replaced once a year. Please contact your local RockShox dealer or the nearest
distributor in the International Distributor List. Read the Warranty section for further warranty repair and contact
information.
Page 10 PN 950-003129-00, Rev. A
Warranty
R S , I .
OCK HOX NC WARRANTS ITS PRODUCTS FOR A PERIOD OF ONE YEAR FROM ORIGINAL DATE OF PURCHASE TO BE FREE FROM
. A R S
DEFECTS IN MATERIALS OR WORKMANSHIP NY OCK HOX PRODUCT THAT IS RETURNED TO THE FACTORY AND IS FOUND BY
R S
OCK HOX TO BE DEFECTIVE IN MATERIALS OR WORKMANSHIP WILL BE REPAIRED OR REPLACED AT THE OPTION OF
T . R
HIS WARRANTY IS THE SOLE AND EXCLUSIVE REMEDY OCK
.
CONSEQUENTIAL DAMAGES
T
HE WARRANTY DOES NOT APPLY TO PRODUCTS WHICH HAVE NOT BEEN PROPERLY INSTALLED AND ADJUSTED ACCORDING TO
. T
INSTALLATION INSTRUCTIONS HE WARRANTY DOES NOT COVER ANY PRODUCT THAT HAS BEEN SUBJECT TO MISUSE OR WHOSE SERIAL
, . T
NUMBER HAS BEEN ALTERED DEFACED OR REMOVED HIS WARRANTY DOES NOT COVER PAINT DAMAGE OR MODIFICATIONS TO THE
. P .
PRODUCT ROOF OF PURCHASE IS REQUIRED

Warranty Repair

If for any reason it should be necessary to have warranty work done, return the product to the place of purchase. In
the USA, Dealers should call for a Return Authorization number (RA#) prior to returning product.
Products returned for inspection must be sent freight prepaid and with proof of purchase to:
R R o o c c k k S S h h o o x x , , I I n n c c . .
4 4 0 0 1 1 C C h h a a r r c c o o t t A A v v e e . .
S S a a n n J J o o s s e e , , C C A A 9 9 5 5 1 1 3 3 1 1
For more technical information, visit our website at www.rockshox.com
Toll-free Technical Support in the USA, call 1.800.677.7177
Customers in countries other than the USA should contact their local dealer or distributor.
IMBA Rules of the Trail
• Ride on open trails only
• Leave no trace
• Control your bicycle
• Always yield trail
• Never spook animals
• Plan ahead
PN 950-003129-00, Rev. A
R S
OCK HOX
S ,
HOX SHALL NOT BE HELD LIABLE FOR ANY INDIRECT SPECIAL
R
Page 11
English
, I .
NC
,
OR
S
OCK HOX