Maintenance; General Inspection; Maintenance Overview; Cleaning The Firebox Glass - HASE LIMAiQ Mode D'emploi

A
A

7 Maintenance

7.1 General inspection

INFO: INSPECTING THE STOVE
The stove must be inspected to prevent defects and ensure safe operation:
► Have your stove professionally inspected at least 1x per year.

7.2 Maintenance overview

7
15
14
13
7
7
12
Flue pipe Firebricks
1 6
Surfaces Door mechanism
2 7
Baffle plate* Fire grate
3 8
Catalytic combustors** Ash drawer
4 9
**
Clean-out port Ash drawer seal
5 10
*Model series iQ
**Model series iQ+
7.3 Maintenance
Stove parts listed in the service and cleaning schedule get very hot during
operation:
► Always perform maintenance with the stove completely cooled
Your stove requires regular maintenance to ensure it is working properly.
The items in table "Service and lubrication schedule" depend on the following
factors:
Fig. 21
▪ Fuel quality
▪ Intensity of use
▪ Heating patterns
▪ Legal requirements
Service and lubricating schedule
MAINTENANCE POINT
Firebox glass
13
Surfaces
2
Control panel
12
Firebox door seal
14
Ash drawer seal
10
1
Fire grate
8
Ash drawer
9
Firebricks
6
Ash compartment
11
Firebricks
6
Flue pipe
1
2
Door mechanism
7
3
Chimney
4
Baffle plate
3
5
Temperature sensor
15
Catalytic combustors
4
6
7
Catalytic combustors
4
*If damaged and there are obvious leaks.
8
**Always vacuum with an industrial vacuum with ash separator.
***Included in the starter kit and available from your HASE authorised dealer.
****Replace catalytic combustor after 2,000 hours of operation.
9
7.3.1 Cleaning the firebox glass
10
If heavily soiled:
11
► Moisten paper towels or newspaper and dip in cold ashes.
► Wipe the glass with it.
Fig. 22
► Dry the glass with dry paper.
Ash compartment
11
For light soiling:
Control panel
12
Firebox glass
13
► Spray glass cleaner on a cloth and wipe the glass with it.
Firebox door seal
14
► Do not use abrasive, corrosive or aggressive
Temperature sensor
15
CAUTION: HOT STOVE PARTS
down.
NOTE: ROUTINE MAINTENANCE
ITEM
Clean
Clean
Clean
Check/replace
Check/replace
Sweep/vacuum**
Empty/vacuum**
Sweep/vacuum**
Vacuum**
Check
Check/sweep
Grease
Have cleaned
Clean flue gas path
Brush
Brush
****
Clean
****
cleaners to prevent damage to the glass surface.
en
WITH WHAT? INTERVAL
Paper towel as required
Paper towel as required
Cloth as required
New seal as required*
New seal as required*
Broom/ash vacuum Daily
Broom/ash vacuum Daily
Broom/ash vacuum Monthly
Ash vacuum Monthly
Eyes Annually
Broom Annually
Speciality grease*** Annually
Chimney sweep Annually
Brush Annually
Brush Annually
After 50 hours
Brush
of operation
Vacuum, wash out, After 200 hours
blow out of operation
107