Engine Maintenance; Checking The Engine Oil Level; Cleaning The Air Filter Element - Ammann AVP 1033 Mode D'emploi

5. Maintenance

5.5 Engine maintenance

These operating
information on daily engine maitenance work.
Observe the engine operating instructions and the
Attention
notes on maintenance and intervals contained in
the same.
5.5.1 Refilling fuel
Only fill fuel with the engine switched off.
No naked flame.
Danger
No smoking!
Do not fill fuel in enclosed areas.
Honda GX 100_15
•
Clean the area around the fuel filler cap.
•
Open the fuel filler cap and check fuel level visually
•
Top up fuel 1) if necessary.
•
Close fuel filler cap tightly
1)
Unleaded fuel according to EN 228

5.5.2 Checking the engine oil level

1
Honda GX 100_01
Place the vibratory plate horizontal
Open the fuel filler cap (1).
Check the oil level and fill to the edge of the fuel filler cap (max.) if
necessary.
Check the dipstick seal and replace if necessary.
Close the fuel filler cap.
instructions only contain
l
1,2
max.
max.
min.

5.5.3 Cleaning the air filter element

3
1
Do not let the engine run without air filter to avoid
premature wear.
Prevent dust entering the carburettor to avoid
Attention
engine damage.
•
Unscrew screws (1) and remove filter cover (2).
•
Remove foam element (3) from the filter cover.
•
Remove paper element (4) from filter housing (5)
Never use petrol or cleaning solutions with a low
flash point for cleaning the filter element; fire and
explosion hazard!
Danger
Cleaning the foam element:
•
Clean with warm soapy water, rinse thoroughly with water and
allow to dry.
Or
•
Clean with a non-flammable solvent and allow to dry.
Cleaning the paper element:
•
Tap the paper element lightly against a hard surface to
remove stubborn dirt.
Or
•
Blow out with compressed air (max. 2 bar) from the clean side
facing towards the engine.
•
Remove dirt on the filter cover and housing with a most cloth
ensuring that no dirt is able to enter the air chamber to the
carburettor.
•
Insert filter elements (3+4), fit cover (2) and tighten screws (1).
If the intake air has a high dust content, the filter
element should be cleaned several times a day as
required.
Important
30
5
4
2
Honda GX 100_02