Batteries: Removal; Lifting And Transporting The Machine - Dustbane Hurricane 400 Manuel D'opération

Batteries: removal

! INFORMATION: The batteries must be removed by qualified technical personnel.
! DANGER: When removing the batteries, the operator must be equipped with suitable personal protection devices (gloves, goggles,
overalls, safety shoes, etc.) to reduce the risk of injury. Make sure to remove the electronic key from the panel before proceeding. Keep
away from naked flames, do not short circuit the battery poles, do not cause sparks and do not smoke.
Proceed as follows:
• Disconnect the battery cables and bridge terminals from the battery poles.
• If necessary, remove the devices fixing the battery to the base of the machine.
• Lift the batteries from the compartment using suitable lifting equipment.
Choosing a battery charger
Specific chargers are required for optimal performance of both Deep Cycle (Lead-Acid) and AGM batteries. Consult Dustbane
literature/distributor to determine which charger is best. Refer to charger literature for more information.

Lifting and transporting the machine

! WARNING: All phases of lifting and moving must be performed in an adequately illuminated environment with the adoption of the
safety measures most appropriate to the situation.The operator must always use personal protection devices.
Proceed as follows to load the machine onto a means of transport:
• Empty the tanks.
• Remove the batteries.
• Push the machine onto the pallet using a sloping ramp, securing the front wheels and the chassis using the brackets
supplied. The machine must not be raised.
• Lift the pallet (with the machine) using a fork lift truck and load it onto the means of transport.
• Anchor the machine to the means of transport with cables connected to the pallet and to the machine itself.
PRACTICAL GUIDE FOR THE OPERATOR
! WARNING: Before starting work, wear overalls, ear protectors, non-slip and waterproof shoes, mask to protect the respiratory tract,
gloves and all other personal protection devices necessitated by the work environment.
! WARNING: Never leave the machine unattended or parked with the electronic ignition key inserted.
! INFORMATION: If you are using the machine for the first time, we recommend trying it out on a large obstacle-free surface first
to acquire the necessary familiarity.
! WARNING: To avoid damaging the surface of the floor you are cleaning, avoid rotating the brushes with the machine stationary.
! WARNING: Always dilute the detergent according to the manufacturer's instructions. Do not use sodium hypochlorite (bleach)
or other oxidants, particularly in strong concentrations. Do not use solvents or hydrocarbons. The water and detergent temperature
must not exceed the maximum indicated in the "Technical specifications". They must be free of sand and/or other impurities.
The machine has been designed for use with low-foam biodegradable detergents made specifically for scrubber dryers.
For a complete and up-to-date list of the detergents and chemicals available, contact the Manufacturer.
Use products suitable for the floor and dirt to be removed only.
Follow the safety regulations on use of detergents given in the section "Safety regulations".
Operations Manual Hurricane 400 XTT / Hurricane 400 XTT – Traction
9