Ingersoll Rand VTR20 Manuel De Maintenance page 5

INTRODUCTION
Ingersoll Rand Oil-Less compressors are the result of advanced engineering and skilled
manufacturing. To be assured of receiving maximum service from this machine, the owner must
exercise care in its operation and maintenance. This book is written to give the operator and
maintenance department essential information for day-to-day operation, maintenance, and
adjustment. Careful adherence to these instructions will result in economical operation and
minimum downtime.
INGERSOLL RAND WARRANTY – V & W SERIES
Ingersoll Rand
warrants each new V & W Series Oil-Less Compressor Pump manufactured by
Rand
to be free from defects in material and workmanship under normal use and service for a period of
thirty six (36) months maximum or specified number of operating hours whichever may occur first. This
applies to the compressor pumps ONLY, excluding head valves which are warranted for the first year only.
The unit is warranted for one year after start or (18) months after shipment, whichever comes first.
The specified operating hours are as follows:
Compression Rings and Guide Rings
Driving Set (sealed ball bearings mounted in connecting rod), Piston Set
Crankshaft Bearing Set
Reed Valves
The above applies to INGERSOLL RAND manufactured compressor units only.
Ingersoll Rand makes no warranty in respect to components and accessories furnished to Ingersoll Rand
by third parties, such as electric motors, aftercoolers, control panels, air receivers, etc. These components
and accessories are warranted only to the extent of the original manufacturer's warranty to Ingersoll Rand.
When a compressor pump or component is changed or replaced during the warranty period, the new/replaced
item is warranted for only the remainder of the original warranty period. Replacement parts purchased during
the normal operation of the unit for non-warranted replacement due to normal wear and tear are warranted
against defects in material and workmanship for a period of ninety (90)days.
Repair, replacement, or refund in the manner and within the time provided shall constitute Ingersoll Rand's
sole liability and your exclusive remedy resulting from any nonconformity or defect. Ingersoll Rand shall not
in any event be liable for any damages, whether based on contract, warranty, negligence, strict liability, or
otherwise, including without limitation any consequential, incidental, or special damages, arising with respect
to the equipment or its failure to operate, even if Ingersoll Rand has been advised of the possibility thereof.
Ingersoll Rand makes no other warranty or representation of any kind, except that of title, and all other
warranties, expressly disclaimed. No salesman or other representative of Ingersoll Rand has the authority
to make any warranties.
Warranty periods are from date of start up by the Distributor or customer at his place of business. If any
extended period of storage prior to start up is expected it is the responsibility of the customer or Distributor to
advise Ingersoll Rand Service Department of the expected storage time prior to start up. If this is longer than
six (6) months it must be advised in writing and approved by Ingersoll Rand to protect the warranty period
after start up.
OIL-LESS COMPRESSOR
EXPRESS LIMITED WARRANTY
IF3163 Rev A Page 5
Ingersoll
10,000 hours or 3 years
10,000 hours or 3 years
20,000 hours or 3 years
5,000 hours or 1 year