Dustbane Gladiator 512 Manuel D'opération page 15

Flap / Bin gasket: check wear of the flaps and gaskets
Dust filter: check that the filter is undamaged and clean
Tires: check that the tires are in good condition and without cuts
at the sides
Battery: check the level of acid in the batteries
General control: check that nuts and screws are tight
Troubleshooting, 512 Ride-On
Battery disconnected.
The battery is flat.
The key switch is in the 0 position.
Emergency button pressed.
Main solenoid switch faulty.
Fuse blown.
Fuse blown.
Fan switch on OFF.
Suction relay faulty.
Motor malfunction.
Fuse blown.
Brush switch not pressed.
Suction relay faulty.
Led 6 (red) on heavy brush pressure.
Motor malfunction.
Fuse blown.
Filter shaker relay faulty.
Filter shaker switch not pressed.
Filter shaker motor faulty.
PROBLEM:
The machine does not function.
CAUSE
PROBLEM:
Suction motor does not function.
CAUSE
PROBLEM:
The center brush does not turn.
CAUSE
PROBLEM:
Filter shaker not working.
CAUSE
 
Connect the battery to the machine.
Recharge the battery.
Turn the key switch to the "1" position.
Release the emergency button.
Replace solenoid switch.
Replace fuse.
Replace fuse.
Press the fan switch.
Replace relay.
Replace the motor.
Replace fuse.
Press the brush switch.
Replace relay.
Reduce the pressure of the center brush on the work surface.
Replace the motor.
Replace fuse.
Replace relay.
Press the filter shaker switch.
Replace filter shaker motor.




SOLUTION
SOLUTION
SOLUTION
SOLUTION
15