Glass And Gasket Replacement; Glass Replacement - Timberwolf TF 100 Mode D'emploi

8.7

gLASS AND gASkET rEPLACEmENT

burning your applianCe With the FireboX Door open or aJar Creates a Fire haZarD
FreQuently eXaMine all Door seals/gasKets, replaCe iF Worn. Failure to shut Fire-
boX Door tightly anD ignoring leaKing gasKets Can result in eXtreMe over Firing
At the end of each burning season inspect the firebox door gasket ensuring that it is not worn or loose. Re-
place with proper fiberglass rope. The purpose of door gasketing is to seal the firebox. If the door is not
sealed, air leaks into the firebox, creating a quick burning fire. This situation is not desirable for overnight or
extended burns.
Replace cracked or broken glass immediately. When re-installing the glass, be sure that the glass and gasket
create a solid seal around door frame. Follow the instructions in Section 8.8 for Glass Replacement.
8.8

gLASS rEPLACEmENT

CARE MUST BE TAKEN WHEN REMOVING AND DISPOSING OF ANY BROKEN DOOR GLASS OR
DAMAGED COMPONENTS. BE SURE TO VACUUM UP ANY BROKEN GLASS FROM INSIDE THE
DO NOT STRIKE, SLAM OR SCRATCH GLASS. DO NOT OPERATE APPLIANCE WITH GLASS
a.
When the appliance is cool, remove the door
and place it face down on a soft surface. Be
careful not to scratch the paint.
b.
Remove the 5 screws securing the glass
retainers.
C. Remove all broken glass.
D. Cut the 3/4" flat gasket into 3 1/2" (89mm)
lengths and affix to glass retainers as
illustrated, ensure the gasket extends past the
ends of the retainers by 1/4" (6mm) .
e. Apply small beads of silicone in the gasket
groove, as shown.
F. Place the rope gasket in the gasket groove, on
top of the silicone.
g. Place the glass on the door. Re-install the glass retainers.
note: For replacement glass, size, thickness and specifications see "replaCeMents" section.
ThaT maY resUlT in a hoUse anD or ChimneY Fire.
!
DO NOT USE SUBSTITUTE MATERIALS.
GLASS MAY BE HOT, DO NOT TOUCH GLASS UNTIL COOLED.
APPLIANCE BEFORE OPERATION.
REMOVED, CRACKED, BROKEN OR SCRATCHED.
WARNING
!
ConDiTions.
WARNING
29
56.2
¾" x 3 ½" (89 mm)
FLAT
GASKET
¼" ROPE
GLASS
GASKET
SILICONE
W415-1133 / A / 06.12.13
EN