Safety Information - Outdoorchef AROSA 570 G Manuel

• NOTE: Check whether the pressure regulator and gas bottle are approved for use in your country. Use only gas bottles that comply with the
applicable national standard. The different sealing systems mean that any discrepancy in the pressure regulator and gas bottle systems will
prevent the secure closure of the seal. This could result in a leakage of gas, which could then be ignited by an open fire or a spark. For safety
and liability reasons, in all cases we recommend checking gas barbecues intended for sale and, if required, adapting the pressure regulator
and gas hose in accordance with national regulations, or arranging for this work to be performed.

SAFETY INFORMATION

This user guide must be kept by the owner and be close at hand at all times.
Light the barbecue in accordance with the INSTRUCTIONS FOR LIGHTING section of this guide.
• "Use outdoors only"
• "Read the instructions before using the appliance"
• "CAUTION: Accessible parts may be very hot. Keep children away."
• "This appliance must be kept away from flammable materials during use"
• "Do not move the appliance during use"
• "Turn off the gas supply at the gas cylinder after use"
• Never use the barbecue under a canopy.
• Appliances equipped with castor wheels must not be pushed across uneven ground or steps.
• Wear protective gloves when touching hot parts.
• After grilling, always turn the gas regulating knob to the position and close the gas supply at the gas bottle.
• When changing the gas bottle, make sure that the gas regulating knob is in the
IMPORTANT: Ensure that there are no ignition sources in the vicinity of the barbecue.
• After connecting a new gas bottle, check the connection parts in accordance with the instructions in the LEAK TEST section.
• If you suspect that parts are leaking, turn the gas regulating knob to the
parts that carry gas checked at a specialist gas equipment retailer.
• Replace the gas hose immediately if it is damaged or displays signs of wear. The hose must be free from kinks and must not have any
cracks. Do not forget to switch off the gas regulating knob and the gas supply before you remove the hose.
• Renew the hose and the gas pressure regulator after it has been in use for 3 years from the date of purchase. Make sure that the gas
pressure regulator and the hose comply with the corresponding EN standards (gas pressure regulator EN 16129 / gas hose EN 16436).
• The recommended length of the gas hose is 90 cm, and it must not be longer than 150 cm.
• Never block the large round air intake hole on the base of the bowl or the air slots in the lid. The ventilation openings in the gas bottle
compartment must never be closed or covered.
• "Do not modify the appliance". Contact a specialist if you suspect there is a malfunction.
• The barbecue is supplied with the appropriate gas hose and gas pressure regulator. It is essential to keep the gas hose away from the hot
outside surfaces of the barbecue. The hose must not be twisted. On barbecue models that have a hose guide, it is essential for the hose
to be secured in this guide.
• The hose and regulator are in accordance with the particular national regulations and EN standards (gas pressure regulator EN 16129 / gas
hose EN 16436).
• Contact a specialist gas equipment retailer if full power is not achieved and you suspect there may be a blockage in the gas supply.
• Only use the barbecue on firm, secure ground. Never place the barbecue on wooden floors or other flammable surfaces while it is in use.
Keep the barbecue away from flammable materials.
• Do not store the barbecue in the vicinity of highly inflammable liquids or materials.
• If you store the barbecue indoors over winter, it is essential for the gas bottle to be removed. It should always be stored outdoors in a well
ventilated location which is inaccessible to children.
• Select a location that is as sheltered as possible from the wind before lighting the barbecue.
• When the barbecue is not in use, and once it has cooled down fully, protect it against weather damage by using a cover. Covers can
be purchased from your barbecue retailer.
• Remove the cover after heavy rain in order to avoid condensation build-up.
• Never leave the barbecue unsupervised during operation.
• The barbecue remains hot for quite some time after being switched off. Make sure you do not burn yourself or place any objects
on the barbecue due to the danger of burns.
OUTDOORCHEF.COM
position and the gas supply is closed at the gas bottle.
position and close the gas supply at the gas bottle. Have the
22
LEAK TEST
WARNING: Ensure that no ignition sources are in the vicinity during the leak test. This also includes smoking. Never check for leaks with a
burning match or a naked flame, and always do this task outdoors.
1. The gas regulating knob must be in the position.
2. Open the gas supply at the bottle and brush a soap solution (50% liquid soap and 50% water) onto all parts that carry gas (connection at the
gas bottle / gas pressure regulator / gas hose / gas inlet / connection on the valve). You can also use a leak spray (see Fig. 2A and 2B).
3. Bubbles forming in the soap solution indicate that there are leaks. IMPORTANT: do not use the barbecue until all leaks have been
eliminated. Turn off the gas supply at the gas bottle.
4. Eliminate the leaks by retightening the connections if possible, or else renew the defective parts.
5. Repeat steps 1 and 2.
6. Contact your specialist gas equipment retailer if the leaks cannot be eliminated.
NOTE: Carry out the LEAK TEST each time the gas bottle is connected or changed, and also at the start of the barbecue season.
AROSA 570 G SPECIFIC DESCRIPTION
Fig. 2A
OUTDOORCHEF.COM
Fig. 2B
23