Trouble Shooting; Spider And Insect Warning - Jackson Grills Supreme JSS550BI-LP Manuel D'utilisation

A) SPIDER AND INSECT WARNING:
Spiders and insects can nest in burners during storage. This hazard has been known to
cause grill fires. Clean the main burners periodically, as well as before storing the grill.
B) BURNER INSPECTION:
Inspect burners each time you use your grill, or immediately if one of the following occurs:
1. Yellow flames with burnt insect odor.
2. Temperature too low or heats unevenly
3. The burners make popping noises.
PROBLEMS
Torch Light pilot
flame will not light:
Main Burner won't
light after torchlight
lights successfully:
No Spark at rear
rotisserie burner:
Inadequate Heat:
Gas valve hard to
turn:
Excessively yellow
or orange flames:
Grease Fire or
Excessive Flame
Flare-ups:
Flame lifts off burner
while in operation:
Knobs getting too
hot:
If you need help trouble shooting, please call the dealer you purchased your grill from or Jackson Grills at 1-888-287-3333.

Trouble Shooting:

POSSIBLE CAUSE
Electrode contaminated w. deposits:
Electrode or wire damaged & no spark:
Electrode wire loose or fallen off:
Plugged Torch Light orifice or outlet tube:
Natural Gas outlet or propane tank delivering low or
no fuel:
Burner orifices plugged/caked w. residue:
Natural Gas outlet or propane tank delivering low or
no fuel:
Air Shutters set incorrectly:
Burner(s) incorrectly installed and misaligned with
valve orifice:
Defective Gas Valve(s):
Dead battery in rear burner ignition switch:
Defective ignition switch/module:
Contaminated rotiss burner electrode
Defective regulator
Low inlet Pressure
Gas hose bent or kinked:
Grill not preheated:
Corrosion at valve stem:
Incomplete combustion:
Excess fat on meat causes fat fire flare-ups:
Excess Grease deposits:
Gas pressure too high:
Air Shutters set incorrectly:
Wind blowing from behind the grill:
Grill is not level:
Use an old tooth brush, some alcohol, and emery paper
to clean electrode tip and insulator.
Replace gas valve assembly complete with wire.
Reconnect electrode wire at gas valve.
Clean torch tube, and/or unplug orifice with fine wire.
Check Nat Gas pressure. Check propane tank empty?
Propane Safety Valve tripped (see PP 9).
Check and clean burners and main valve orifices.
Check Nat Gas pressure. Check propane tank empty?
Propane Safety Valve tripped (see PP 9).
Re-set burner air shutters until flame characteristics are
similar to pg. 15.
Re-install burner(s) correctly so that the orifice is
centered in the burner's inlet.
Replace gas valves as needed.
Replace battery by unscrewing switch cap
Replace ignition switch/module
Use an old tooth brush, some alcohol, and emery paper
to clean electrode tip and insulator.
Replace NG Regulator OR Propane Hose & Regulator
Check NG gas pressure, check propane tank empty?
Smooth out the hose and check for damage
Preheat the grill for 15 minutes, minimum
Remove knob and lube with penetrating oil; work valve
back and forth to loosen; lube regularly.
Re-set burner air shutters so flame characteristics are
similar to pg. 15.
Trim fat off meat before grilling (NOTE: check and empty
grease tray regularly)
Regularly clean Firebox, Grease Pan, and Grease Cup
NOTE; check grease cup prior to each use of grill.
Call a professional gas fitter or Propane dealer
Re-set burner air shutters until flame characteristics are
similar to pg. 15.
Reposition grill or create wind barrier.
Reposition grill.
21
SOLUTIONS