CAME BY-3500T Manuel D'installation page 22

• T
HIS PRODUCT SHOULD
WHICH IT WAS EXPLICITLY DESIGNED
CAME S. .A.
P IS NOT
,
IMPROPER WRONGFUL AND UNREASONABLE USE
WITH THE INSTALLATION AND OPERATION MANUALS THAT COME WITH THE OPERATOR
B
EFORE INSTALLING
( ' :
CHECKING WHAT S THERE IF SOMETHING IS MISSING
HAVE COMPLIED WITH ALL SAFETY PROVISIONS
• C
HECK THAT THE AUTOMATED PARTS ARE IN PROPER MECHANICAL ORDER
THE OPERATOR IS LEVEL AND ALIGNED
M
AKE SURE YOU HAVE SUITABLE MECHANICAL STOPS
INSTALLED AT A HEIGHT OF LESS THAN
,
LEVEL MAKE SURE YOU HAVE ANY NECESSARY PROTECTIONS AND
• I
IN PLACE F ANY PEDESTRIAN OPENINGS ARE FITTED INTO THE OPERATOR
MUST ALSO BE A A SYSTEM TO BLOCK THEIR OPENING WHILE THEY ARE MOVING
M
AKE SURE THAT THE OPENING AUTOMATED DOOR OR GATE CANNOT ENTRAP PEOPLE
AGAINST THE FIXED PARTS OF THE OPERATOR
. I
ELEMENTS THAT COULD BEND F NECESSARY
• D
ANCHORING POINTS O NOT INSTALL DOOR OR GATE LEAVES ON TILTED SURFACES
• M
AKE SURE ANY SPRINKLER SYSTEMS CANNOT WET THE OPERATOR FROM THE
• M
GROUND UP AKE SURE THE TEMPERATURE RANGE SHOWN ON THE PRODUCT
LITERATURE IS SUITABLE TO THE CLIMATE WHERE IT WILL BE INSTALLED
INSTRUCTIONS AS IMPROPER INSTALLATION MAY RESULT IN SERIOUS BODILY INJURY
I
T IS IMPORTANT TO FOLLOW THESE INSTRUCTIONS FOR THE SAFETY OF PEOPLE
.
THESE INSTRUCTIONS
• S
UITABLY SECTION OFF AND DEMARCATE THE ENTIRE INSTALLATION SITE TO PREVENT
UNAUTHORIZED PERSONS FROM ENTERING THE AREA
• B
CHILDREN E CAREFUL WHEN HANDLING OPERATORS THAT WEIGH OVER
I ,
F NEED BE USE PROPER SAFETY HOISTING EQUIPMENT
( , ,
THAT IS BUTTONS KEY SWITCHES
1.85
INSTALLED AT LEAST M FROM THE PERIMETER OF THE GATE
OR WHERE THEY CANNOT BE REACHED FROM OUTSIDE THE GATE
( ,
COMMANDS WHETHER BUTTONS TOUCH PANELS
1.5
LEAST M FROM THE GROUND AND MUST NOT BE REACHABLE BY UNAUTHORIZED
• A
PERSONS LL MAINTAINED ACTION COMMANDS
WHICH THE MOVING GATE LEAVES AND TRANSIT AND DRIVING AREAS ARE VISIBLE
A , ,
PPLY IF MISSING A PERMANENT SIGN SHOWING THE POSITION OF THE RELEASE
• B
DEVICE EFORE DELIVERING TO THE USERS
12453 (
STANDARD COMPLIANT REGARDING IMPACT FORCES
THE SYSTEM HAS BEEN PROPERLY ADJUSTED AND THAT ANY SAFETY
AND MANUAL RELEASE DEVICES ARE WORKING PROPERLY
WHERE NECESSARY AND IN A VISIBLE PLACE
S -
PECIAL USER INSTRUCTIONS AND RECOMMENDATIONS
• K
EEP GATE OPERATION AREAS CLEAN AND FREE OF ANY OBSTRUCTIONS
SURE THAT THE PHOTOCELLS ARE FREE OF ANY OVERGROWN VEGETATION AND THAT
'
THE OPERATOR S AREA OF OPERATION IS FREE OF ANY OBSTRUCTIONS
ALLOW CHILDREN TO PLAY WITH FIXED COMMANDS
. K
MANEUVERING AREA EEP ANY REMOTE CONTROL TRANSMITTERS OR ANY OTHER
COMMAND DEVICE AWAY FROM CHILDREN
. • T
ACCIDENTALLY ACTIVATED HE APPARATUS MAY BE USED BY CHILDREN OF EIGHT
YEARS AND ABOVE AND BY PHYSICALLY
,
PEOPLE OR EVEN ONES WITHOUT ANY EXPERIENCE
CLOSE SUPERVISION OR ONCE THEY HAVE BEEN PROPERLY INSTRUCTED TO USE THE
APPARATUS SAFELY AND TO THE POTENTIAL HAZARDS INVOLVED
. C
NOT PLAY WITH THE APPARATUS
,
NOT BE DONE BY CHILDREN UNLESS PROPERLY SUPERVISED
THE SYSTEM FOR ANY MALFUNCTIONS OR SIGNS OF WEAR AND TEAR OR DAMAGE
,
TO THE MOVING STRUCTURES TO THE COMPONENT PARTS
INCLUDING CABLES AND ANY ACCESSIBLE CONNECTIONS
JOINTS AND SLIDE RAILS PROPERLY LUBRICATED
ON THE PHOTOCELLS AND SENSITIVE SAFETY EDGES
WHETHER THE PHOTOCELLS ARE WORKING
important safety instructions for people:
P
REMISE
ONLY BE USED FOR THE
. A
NY OTHER USE IS DANGEROUS
LIABLE FOR ANY DAMAGE
• K
EEP THESE WARNINGS TOGETHER
,
DO NOT CONTINUE UNTIL YOU
)
,
AND THAT IT OPENS AND CLOSES PROPERLY
• I
F THE OPERATOR IS TO BE
2.5
M FROM THE GROUND OR OTHER ACCESS
• D
O NOT FIT UPSIDE DOWN OR ONTO
,
ADD SUITABLE REINFORCEMENTS TO THE
I
NSTALLING
,
ESPECIALLY MINORS AND
• A
LL OPENING COMMANDS
, ,
MAGNETIC READERS AND SO ON
'
S WORKING AREA
. A
LSO
, )
AND SO ON MUST BE INSTALLED AT
,
MUST BE FITTED IN PLACES FROM
,
MAKE SURE THE SYSTEM IS
),
AND ALSO MAKE SURE
• A W
PPLY
, ( ,
SUCH AS SUCH AS THE GATE
,
OR TO LOITER IN THE GATE
,
TO PREVENT THE OPERATOR FROM BEING
,
MENTALLY AND SENSORY
,
PROVIDED THIS HAPPENS UNDER
. C
LEANING AND MAINTENANCE BY USERS MUST
• F
REQUENTLY CHECK
,
ALL ANCHORING POINTS
. K
EEP ANY HINGES
• P
ERFORM FUNCTIONAL CHECKS
,
EVERY SIX MONTHS
,
WAVE AN OBJECT IN FRONT OF THEM
WARNING!
READ CAREFULLY!
WHILE THE GATE IS CLOSING
OR SUDDENLY STOPS
PURPOSE FOR
.
MAINTENANCE OPERATION TO DO WITH THE POWER ON
'
PHOTOCELLS GLASS COVERS USING A SLIGHTLY WATER
CAUSED BY
USE SOLVENTS OR OTHER CHEMICAL PRODUCTS THAT MAY RUIN THE DEVICES
REPAIRS OR MODIFICATIONS ARE REQUIRED TO THE SYSTEM
.
AND DO NOT USE IT UNTIL SAFETY CONDITIONS HAVE BEEN RESTORED
THE POWER SUPPLY BEFORE RELEASING THE OPERATOR FOR MANUAL OPENINGS AND
BEFORE ANY OTHER OPERATION
R
EAD THE INSTRUCTIONS
,
THAT REPLACED BY THE MANUFACTURER OR AUTHORIZED TECHNICAL ASSISTANCE SERVICE
.
OR IN ANY CASE
FORBIDDEN
EXPRESSLY REQUIRED OF THEM AND WHICH ARE NOT LISTED
. F
/
THE MANUALS
OR WARNINGS
,
ORDINARY MAINTENANCE
THERE
•
AND CHECKS INTO THE PERIODIC MAINTENANCE LOG
• K
EEP CLEAR OF HINGES AND MECHANICAL MOVING PARTS
'
OPERATOR S AREA OF OPERATION WHEN IT IS MOVING
'
OPERATOR S MOVEMENT AS THIS COULD RESULT IN DANGEROUS SITUATIONS
PAY SPECIAL ATTENTION TO ANY DANGEROUS POINTS
WITH SPECIFIC PICTOGRAMS AND
• F
OLLOW ALL
A SELECTOR SWITCH OR A COMMAND IN MAINTAINED ACTIONS
•
THERE ARE NO PERSONS WITHIN THE OPERATING RANGE OF ANY MOVING PARTS
. K
EEP
THE COMMAND IS RELEASED
• A
WARNING
MAINTENANCE OR CLEANING
20 .
KG
)
MUST BE
,
,
ANY DIRECT
•
EN
,
PROTECTION
S
ARNING IGNS
'
S PLATE
. M
AKE
• D
O NOT
'
S
-
CHALLENGED
Danger of foot crushing
HILDREN MUST
Danger of hand crushing
,
, Danger! High voltage.
MOVING
. T
O CHECK
No transiting while the barrier is moving
;
IF THE OPERATOR INVERTS ITS DIRECTION OF TRAVEL
,
THE PHOTOCELLS ARE WORKING PROPERLY
,
TO PREVENT POTENTIALLY HAZARDOUS SITUATIONS
I
F THE POWER SUPPLY CABLE IS DAMAGED
,
BY SIMILARLY QUALIFIED PERSONS
OPERATIONS THAT ARE NOT
FOR USERS TO PERFORM ANY
,
OR ANY REPAIRS MODIFICATIONS
, CALL TECHNICAL ASSISTANCE • L
F
URTHER RECOMMENDATIONS FOR ALL
/
OR BLACK AND YELLOW STRIPES
• T
HE GATE MAY MOVE AT ANY TIME AND WITHOUT
LWAYS CUT OFF THE MAINS POWER SUPPLY BEFORE PERFORMING ANY
.
. T
HIS IS THE ONLY
. C
ONSTANTLY CLEAN THE
- ;
MOISTENED CLOTH DO NOT
• I
F
,
RELEASE THE OPERATOR
• C
UT OFF
.
,
IT MUST BE
,
, • I
TO PREVENT ANY RISK T IS
IN
/ , -
ADJUSTMENTS AND FOR EXTRA
OG THE JOB
.
• D
O NOT ENTER THE
• D
O NOT COUNTER THE
• A
LWAYS
,
WHICH HAVE TO BE LABELED
• W
HILE USING
,
KEEP CHECKING THAT
,
UNTIL