Enerzone Solution 3.5 Manuel D'installation Et D'utilisation page 164

Report prepared for: Guillaume Thibodeau-Fortin (Stove Builder International Inc.) on 9/6/2018 2:01:07 PM
Test report 103536746MTL-002 (17 of 21)
TEST REPORT FOR STOVE BUILDER INTERNATIONAL INC.
Report No.: 103536746MTL-002
Date: 07/13/18
The air control was opened for 16.5 minutes or when 15% of the load weight has been
consumed, and then set at the lowest burn rate. The fan was turned on at low speed at 30
minutes. Due to a bad manipulation in the post leak check of the sampling system, black soot got
sucked by one of the filter train. After weighting, the deviation ratio was above 7.5 % which leads
to an invalid test run.
RUN #2 (May 23
a category "Low burn rate" of 1.3 kg/hr. Let the door ajar for 6.5 minutes, and then closed. The air
control was opened for 16.5 minutes or when 15% of the load weight has been consumed, and
then set at the targeted burn rate. The fan was turned on at low speed at 30 minutes.
RUN #3 (May 24
a category "Medium burn rate" of 1.7 kg/hr. Let the door ajar for 6.5 minutes, and then closed.
The air control was opened for 16.5 minutes or when 15% of the load weight has been
consumed, and then set at the targeted burn rate. The fan was turned on at medium speed at 30
minutes.
RUN #4 (May 25
High burn rate of 3.9 kg/hr. The door was open for 5 minutes, then closed. The air control was
fully opened. Start the fan at full speed.
TABLE 1 – EMISSIONS
RUN# TEST
DATE
May 23,
2
2018
May 24,
3
2018
May 25,
4
2018
*Data including the cold-Start
TABLE 2 – TEST FACILITY CONDITIONS
RUN ROOM
# TEMP
BEFORE
(°F)
2
3
4
TABLE 3 – DILUTION TUNNEL FLOW RATE MEASUREMENTS AND SAMPLING DATA
Version: 05/10/17
Stove Builder International Inc. | 44826 | Rev: Aug 31 2018 3:17PM | Uncontrolled Copy
rd
2018) Air control set at the targeted burn rate, burn time was 600 minutes with
th
2018) Air control set at the targeted burn rate, burn time was 470 minutes with
th
2018) Air control set fully opened, burn time was 200 minutes with a category
BURN RATES PARTICULATE
(kg/hr)(Dry) EMISSION
RATE (g/hr)
0.74
1.3
1.48
1.7
2.18*
*1
3.9
ROOM BARO
TEMP PRES
AFTER BEFORE
(°F) (in/Hg)
85 84 30
87 86 30
73 89 30
st
1 HOUR CO EMISSIONS
EMISSIONS (g/min)
(g)
6.34
5.29
4.59
BARO R. H. R. H.
PRES BEFORE AFTER
AFTER (%) (%)
(in/Hg)
30 28 21
30 17 13
30 32 23
Page 17 of 21
8431 Murphy Drive
Middleton, WI 53562
Telephone: 608-836-4400
Facsimile: 608-831-9279
www.intertek.com/building
HEATING
EFFICIENCY
(%HHV)
1.3
72%
1.7 71%
1.4 68%
AIR VEL AIR VEL
BEFORE AFTER
(ft/min) (ft/min)
0 0
0 0
0 0
GFT-OP-10c
Page 172 of 201