Maintenance And Storage - Kong ORTLES Instructions D'utilisation Et D'entretien

MAINTENANCE AND OPERATING INSTRUCTIONS
rest plates or on the
The "ORTLES" winch, assembled on the rest plates or on the "STELVIO" fishing pole, supplied
with a static textile rope with 10.5 mm diameter in conformity with the norm prEN 1891, is in
conformity with the Regulation 89/392/EEC and with the norm EN 1496 as a device belonging to
the class B.
NOTE:Your life depends on your equipment. The user must know the story of his equipment (use,
storage, controls). If the equipment is not for one's personal use (e.g. mountain centres, clubs,
rescue stations etc.), we strongly suggest that the pre-use controls are carried out by an expert
and qualified person and that they are recorded in the control charts given in the following. No
responsibility for damages, wounds or death caused by wrongful use, nor for items which have
been modified or repaired by non-authorized persons will be assumed by Kong S.p.A.
Before using any new device Kong S.p.A. suggest to carry out accurate practical tests in order
to get a good knowledge of them and to verify in advance their perfect suitability for the specific
use they have been designed for. As a matter of fact, neither the instructions nor the laboratory
tests can reproduce all possible conditions of employment in case of rescue or emergency.
We pay great attention to the resistance of all the anchor devices, whether they are natural or
not, because they can not be guaranteed and therefore we need the opinion of expert users to
achieve a fair safety. Please remember that the position of the anchor devices is very important,
because it must guarantee the motionlessness of these devices when they work under stress.
Kong technicians are at any time at your disposal for further information and suggestions for the
correct use of any Kong items
No maintenance is required. The user has just to clean the device as explained in the following.
1) CLEANING: In case of dirt, wash with lukewarm drinking water (max 40°) adding a delicate
cleansing product, if necessary (mild soap). The cleaning after the use in saline environments
is particularly recommended. The drying must take place far from any source of heat.
2) DISINFECTION:
disinfectant, then wash it with drinking water.
3) STORAGE: After cleaning and drying the device put it in its rucksack in a dry, cool and dark
place (avoid ultraviolet radiation), which must be chemically neutral (avoid saline environments
definitely), far from sharp corners, sources of heat, humidity, corroding substances or other
possible harmful conditions. Do not store wet!!
4) LUBRICATION: If necessary, lubricate by using an oil containing silicone.
Rest plates and pole: oil the screws of the fastening hand levers and the threaded bushes.
Ortles winch: oil the mechanism of the rope blocking device. Never remove the winch drum
(in case of problems contact Kong or the authorized dealer).
KONG s.p.a. Zona Industriale -
TEL. + 39 0341 630506 • FAX. + 39 0341 641550 • EMAIL: kong@kong.it • WEB SITE: http://www.kong.it
STELVIO fishing pole..
Device belonging to the class B-EN 1496

MAINTENANCE AND STORAGE

Let the cloth soak in lukewarm water (max 20°) with the addition of a
via XXV Aprile, 4 - 23804 MONTE MARENZO (LC) - ITALY
of the ORTLES
NOTE
winch assembled on the
1