Maintenance; Repairs - WAGNER PLASTMAX Mode D'emploi

PlastMax
8

MAINTENANCE

Maintenance must be performed by ade-
quately trained personnel, after switching
off the machine, disconnecting it from the
power supply and emptying the hopper.
Check daily that the water filter (fig. 19, 1) is clean.
Check once a week that the compressor-air filter (fig. 19, 2) is
clean. If it shows signs of wear and tear or is damaged, it must
be replaced.
Check that the mixer is functioning properly once a week, and
replace if necessary.
Check weekly that the electric motors are free of dust and dirt
and if necessary clean using compressed air.
Check weekly that the plug and socket contacts are clean, dry
and rust free.
Every 12 months arrange for an inspection of the machine by
an authorised Wagner service centre.
Spent oil is a special waste. Therefore it
must be disposed of according to current
legislation.
Always keep notices and symbols on the
machine legible.
2
9

REPAIRS

Do no operate the mixing pump during
repair work.
Repairs to electrical fittings may only be
carried out by specialist personnel.
When required, use only original Wagner
spare parts that have not been modified in
any way.
If protective covers have to be removed
during the repair work, make sure they are
mounted correctly afterwards.
The emergence of alternately hard and software material can
be the sign of wear and tear to the pump.
To replace the stator/rotor, proceed as follows:
Attention! Before disassembly, make sure
that no residual pressure remains. Watch
the manometer ––> 0 bar.
Switch off machine and disconnect from
power supply.
Release the handle to the left of the container.
Position the pipe wrench at the end of the mixer and turn it so
that the rotor can be taken out of the inside of the stator.
Close the handle, put the funnel unit at an angle and block it
in a raised position. Dismantle the collective material pipe and
mount the new rotor/stator pair.
Before assembling the rotor in the stator, spray the thread-
parts with a lubricant spray, available from Wagner. Never use
mineral oil or grease, as this can damage the stator. Avoid the
use of any benzenes.
1
GB
45