Periodic Checks; Periods Of Inactivity - Dustbane Labrador Serie Manuel D'opération

Replacing the squeegee blades
• Lower the squeegee.
• Remove the suction hose from the squeegee
• Lift the squeegee fastening levers.
• Remove the squeegee from the slots on the support.
• Open the hook (Fig. 20, ref. 1).
• Push the two blade pressing devices (Fig. 20, ref. 2) outwards,
then remove them.
• Remove the blade.
• Reuse the same blade by reversing the edge in contact with the floor
un til all four edges are worn out, or replace with a new blade, fitting
it onto the screws on the body of the squeegee.
• Reposition the two blade pressing devices by centering the wider part of the slots on the squeegee body fastening pins,
then push the blade pressing devices inwards.
• Close the hook again.
• Replace the squeegee on its support, following the instructions described previously.

Periodic Checks

Checks
Empty and wash the dirty water tank
Clean the squeegee blades and check them for wear
Check that the suction hole in the squeegee is not blocked
Recharge the batteries
Clean the dirty water tank float
Clean the suction motor air filter
Clean the water/detergent tank filter
Clean the suction motor hose
Clean the dirty water tank and the solution tank
Check the battery electrolyte level
Have the electrical circuit checked by qualified cleaning personnel

Periods of Inactivity

If the machine is not used for some time, for example, on display in a showroom or stored in the warehouse for a period or more
than one month, the following operations are required:
• Recharge completely the batteries. During long periods of inactivity, you should charge the batteries regularly (at least
once every two months) to keep them constantly at maximum charge.
• Disconnect the batteries from the machine.
• Unplug the battery charger (if present) from the mains power supply.
• Remove the squeegee and brushes (or abrasive disks), wash them and put them away in a dry place (preferably in a bag
or wrapped in plastic film) away from dust.
• Make sure the tanks are completely empty and perfectly clean.
18
Parts & Operations Manual Labrador
Daily Weekly
Operations Operations
X
X
X
X
X
X
X
X
X
X
Six Monthly
Operations
X