Technical Specification; Parts List - Earlex 5900 Mode D'emploi

SAFETY OPERATING INSTRUCTIONS
PLEASE READ BEFORE USE
P
• Never under any circumstances aim the Spray Gun at another person or animal. In the event
of injury occurring seek expert medical advice immediately.
• The Spray Gun must only be used with paints and solvents that have a flash point suitable for
spraying. If in doubt, consult the paint or solvent manufacturer's data.
• Always ensure there is adequate ventilation when spraying.
• NEVER spray near a naked flame, including appliance pilot light.
• NEVER smoke whilst spraying.
• NEVER allow children to operate or play with the Spray Gun.
• Always read the solvent manufacturer's instructions before use.
• Always disconnect unit from mains supply when filling the paint container.
• Always wear a suitable protective mask when spraying. We would also recommend the use of
gloves, goggles and overalls.
• After each use, thoroughly clean the Spray Gun and grease the Fluid Needle.
• This appliance is not intended for use by persons (including children) with reduced
physical, sensory or mental capabilities, or lack of experience and knowledge, unless they
have been given supervision or instruction concerning use of the appliance by a person
responsible for their safety.
• Use only genuine manufacturer replacement parts.
• Always disconnect the Spray Station from the mains supply before cleaning the
appliance.
• Warning. The use of any accessory or attachment, other than those recommended in this
instruction manual, may present a risk of personal injury.
• Use the Spray Gun for the job it was designed for only. Mis-use of the Spray Gun will invalidate
the guarantee.
• Wear ear protection.
WARNING: The substances used with this Spray Gun (paints, solvents, etc.) may contain
dangerous, harmful, explosive or corrosive materials. ALWAYS COMPLY WITH THE
SAFETY INSTRUCTIONS ISSUED WITH THIS PRODUCT AND THE MATERIAL BEING USED.
Only use the Spray Station as described in this manual.

TECHNICAL SPECIFICATION:

Wattage: 650 Watts
Voltage: 230 V
Air output: 18L/sec
Sound pressure level: 85 dB (A)
Maximum viscosity: 150DIN/sec (100DIN/sec with the Spray Pack)
THIS MODEL IS NOT SUITABLE FOR USE IN THE UK

PARTS LIST

No Description
01. Air Cap Ring
D
02. Air Cap
03. Spray Direction Plate
04. Fluid Tip (2.5 mm)
05. Fluid Tip Seal
06. Fluid Needle (2.5 mm)
07. Spring
08. Fluid Adjusting Screw
09. Gland Nut
10. Gland Seal
11. Pick-up Tube
Fig.1
Container capacity: 0.9 litres and 4 litres
Air hose length: 4 m
Dynamic air pressure: 0.18 bar
Part No No Description
L0215 12. Paint Container Seal
L0205 13. Paint Container
L0206 14. Hose Assembly
L0531 15. Viscosity Cup
L0211 16. Filter
L0550 17. Hose Clip
L0216 18. Hose Clip
L0210 19. Screw (x4)
L0208 20. Trigger
L0272 21. Pivot Pin
L0214 22. Hose Adapter
2
Part No
L0335
L0878
L0896
SG243
L0290
L0505
L0506
L0639
L0202
L0209
L0893