Storage And Transportation - 3M Versaflo TR-302E Manuel D'utilisation

DOFFING
Do not remove the headtop or turn off the air supply until you have vacated the
contaminated area.
1. Lift the Headtop off the head.
2. Switch off the Powered Air Turbo by pressing the power button for 2 seconds.
3. Unbuckle the waist belt.
Note: When removing the lter, hold the Powered Air Turbo facing downwards (cover
towards the ground) to help minimise the potential for contamination of the motor/fan
during cover and lter removal.
For long-term storage of lters, remove the lter and seal in a closed container. 3M does
not recommend the lter be left in place in the Powered Air Turbo as damage may occur
to the lter gasket.
NOTE If the respirator has been used in an area that has caused it to become
contaminated with a substance requiring special decontamination procedures it
should be placed in a suitable container and sealed until it can be decontaminated
or discarded.
CLEANING INSTRUCTIONS
Use a clean cloth dampened with a mild solution of water and liquid household soap.
Do not use petrol, chlorinated degreasing uids (such as trichloroethylene), organic
solvents or abrasive cleaning agents to clean any part of the equipment.
To disinfect use wipes as detailed in Reference Lea et.
^ Keep lter seal clean
^ Never attempt to clean lters by knocking or blowing out accumulated material.
The spark arrestor can be cleaned using water and liquid household soap. Completely dry
the spark arrestor with a clean cloth. If it cannot be cleaned or is damaged then it should
be replaced.
Do not immerse the battery pack or battery charger into any type of liquid.
Do not wipe the electrical contacts.
MAINTENANCE
Maintenance, servicing and repair must only be carried out by properly trained personnel.
^ Use of unapproved parts or unauthorised modi cation could result in danger to
life or health and can invalidate any warranty.
If disposal of parts is required this should be undertaken in accordance with local health
and safety and environmental regulations.
^ Dispose of lithium ion battery packs according to local environmental regulations.
Do not dispose of in standard waste bins, in a re or send for incineration.
Remove the battery by pressing on the battery latch and pulling the battery down and out.
Select an approved charger kit and refer to the user instructions provided with the kit.
^ Do not charge batteries with unapproved chargers, in enclosed cabinets without
ventilation, in hazardous locations or near sources of high heat.
^ Do not charge the batteries outside the recommended temperature range of 0-40°C.
The battery may be left on the charger. However, for long term storage of the batteries,
3M recommends that they are stored off the charger at approximately 40% charge. The
battery should never be left in a discharged state.
The standard economy battery lifetime is at least 1000 hours.
The high capacity battery lifetime is at least 2000 hours.
The battery is expected to maintain at least 80% of initial capacity for lifetime stated
above.
WHAT WHEN
Air ow Check Before use
General Inspection Before use - Monthly if not in regular use
Cleaning After use
FAULT FINDING
Warnings Display Sounder
Low Battery
Low Flow
Low Flow and Battery
Odour Detected
Key = Slow Flash = Short Intermittent Beep
B E
NOTE: POWERED AIR TURBO WILL SHUT DOWN APPROXIMATELY 10-15 MINUTES
BEYOND LOW BATTERY WARNING OR IF INTERNAL BATTERY TEMPERATURE
EXCEEDS 60°C.

STORAGE AND TRANSPORTATION

^ Ensure lters and batteries are stored in accordance with instructions below.
This product should be stored in the packaging provided in dry, clean conditions, away
Comments
1. Charge battery
E
2. Battery pack has exceeded
operating temperature of 55°C
Hose blocked - Clear / Replace hose
E
Filters blocked - Replace lters
(Fig 3 and 4)
See above
E
Replace lter Note: Applicable to
nuisance odour lters only
from direct sunlight, sources of high temperature, petrol and solvent vapours.
Do not store outside the temperature range -30°C to +50°C or with humidity above 90%.
If the product will be stored for an extended period of time before use, the suggested
storage temperature is 4°C to 38°C.
When stored as stated, the expected shelf life (prior to use) of the Powered Air Turbo and
the lter is 5 years from date of manufacture. For storage beyond 2 years, the Powered
Air Turbo should be run for at least 10 minutes once a year.
The expected shelf life (prior to use) of the battery is 9 months from date of manufacture.
The original packaging is suitable for transporting the product.
TECHNICAL SPECIFICATION
(Unless otherwise stated in the Reference Lea et)
Respiratory Protection
EN12941
Nominal and Assigned Protection Factors: please see relevant Headtop User Instructions
Outlet Flow Characteristics
Manufacturers Minimum Design Flow (MMDF) 170 l/min
Audible Alarm
85dB(A) at 10cm
Battery Duration
Standard economy battery pack (11.1V, 2.6 Ah Li metal rechargeable) = 4.5-6 hour
duration*
High capacity battery pack (11.1V, 4.8 Ah Li metal rechargeable) = 9-12 hour duration*
* Estimated system duration based on testing with a new battery and a new, clean lter at
20°C. Actual system duration may be extended or shortened depending on system
con guration and environment.
Charge Time: Standard economy battery pack = less than 3 hours
High capacity battery pack = less than 3.5 hours
Operating Conditions
-10°C to +54°C (54°C limited by battery)
Weight (including high capacity battery, belt and lter)
TR-302E = 1082g
70