Vetus SAPRO Instructions D'installation Et D'utilisation page 8

1 Introduction
The Vetus SAPRO allows waste water from the toilet, washba-
sin, shower, dishwasher, air conditioner etc. to be pumped away
by one piece of equipment.
The equipment is not designed for industrial use.
The Vetus SAPRO may only be used for pulverising and
disposing of faeces, toilet paper and waste water from
other sanitary equipment.
The Vetus SAPRO is not suitable for pulverising other
objects such as cotton wool, tampons, sanitary towels,
condoms and hairs, or for pumping away liquids such as
oil. This can cause damage to the installation!
Make sure that rubber gloves are always available on board.
2 Working
When the water level in the container reaches a set level the
motor will be started by a signal from the built-in float switch and
the water will be pumped out.
The level is set so that every time the toilet is flushed the motor
will start and the toilet waste will be pulverised.
3 Installation
3.1 General
Position the SAPRO behind a wall or under a floor.
Make sure that the SAPRO always remains accessible by fitting
a hatch in the wall or floor.
Use the 2 fitting lugs to hang up the SAPRO.
Always tighten all hose connections with good quality hose
clamps!
Preferably position the
SAPRO amidships and
lengthwise in the ship.
6
11.0111
N.B.!
SAPRO15
Install the SAPRO while the ship is at rest and then fit the
SAPRO on a horizontal surface.
The SAPRO is guaranteed to work correctly at angles up to 10˚
from fore to aft and 20˚ athwartships.
MAX.
10°
3.2 Summary of connections
1 Toilet
2 (For example)
Washbasin
or shower
1
3 Air vent
4 Drain
2
3.3 Connection 1 (toilet)
Use tube or hose with external diameter of 102 mm for connect-
ing a toilet. The use of T pieces allows more than one toilet to
be connected to the SAPRO.
N.B.!
The drain must have a minimum gradient of 5%.
3.3.1 Tube
Moisten the end of the tube with a lubricant (such as liquid
soap) and slide the sleeve piece of the SAPRO over the end of
the tube.
W.L.
W.L.
SAPRO14
4 3 2
2
SAPRO01
SAPRO02
SAPRO13
MAX.
20°
SAPRO