Maintenance And Service; Maintenance And Cleaning; After-Sales Service And Application Service; Transport - Bosch Drive Unit Notice Originale

Influences on the Operating Range
The range is affected by a number of factors, such as:
– Assistance level
– Speed
– Gear changing behaviour
– Tyre type and tyre pressure
– Age and condition of the battery
– Route profile (gradients) and conditions (road surface)
– Headwind and ambient temperature
– Weight of eBike, driver and luggage.
For this reason, it is not possible to precisely predict the
range before and during a trip. General rules:
– With the same assistance level on the eBike drive: The less
energy you need to exert in order to reach a certain speed
(e.g. by changing gears optimally), the less energy the
eBike drive will consume and the higher the range per bat-
tery charge will be.
– The higher the assistance level under otherwise same con-
ditions, the lower the range.
Careful Handling of the eBike
Please observe the operating and storage temperatures of the
eBike components. Protect the drive unit, on-board computer
and battery against extreme temperatures (e.g. from intense
sunlight without adequate ventilation). The components (es-
pecially the battery pack) can become damaged through ex-
treme temperatures.
Keep the screen of your Nyon clean. Dirt can cause faulty
brightness detection. The day/night switch-over in the navi-
gation mode can be distorted.
An abrupt change of environmental conditions, can cause the
screen to fog up from inside. After a short time, a temperature
adjustment takes place and the fog disappears.

Maintenance and Service

Maintenance and Cleaning

Keep all components of your eBike clean, especially the bat-
tery-pack contacts and corresponding holder contacts. Clean
them carefully with a soft, damp cloth.
Do not immerse any components, including the drive unit, in
water or clean them with pressurised water.
Have your eBike checked by an expert at regular intervals. The
on-board computer displays a message telling you when the
service date is due for four seconds after switching it on. The
bicycle manufacturer or dealer may base the service date on
the distance travelled and/or on a period of time.
For service or repairs on the eBike, please refer to an author-
ised bicycle dealer.
 Have all repairs performed only by an authorised bike
dealer.
Bosch eBike Systems

After-sales Service and Application Service

In case of questions concerning the eBike system and its com-
ponents, please refer to an authorised Bosch eBike dealer.
For contact data of authorised Bosch eBike dealers, please
refer to www.bosch-ebike.com

Transport

 If you transport your eBike attached to the outside of
your car, e.g. on a bike rack, remove the on-board com-
puter and the PowerPack to avoid damaging them.
The battery packs are subject to the Dangerous Goods Legis-
lation requirements. Private users can transport undamaged
battery packs by road without further requirements.
When being transported by commercial users or third parties
(e.g. air transport or forwarding agency), special require-
ments on packaging and labelling must be observed (e.g. ADR
regulations). If necessary, an expert for hazardous materials
can be consulted when preparing the item for shipping.
Dispatch battery packs only when the housing is undamaged.
Tape or mask off open contacts and pack up the battery pack
in such a manner that it cannot move around in the packaging.
Inform your parcel service that the package contains danger-
ous goods. Please also observe the possibility of more de-
tailed national regulations.
In case of questions concerning transport of the battery packs,
please refer to an authorised Bosch eBike dealer. The Bosch
eBike dealers can also provide suitable transport packaging.
Disposal
The drive unit, on-board computer including operat-
ing unit, battery pack, speed sensor, accessories and
packaging should be disposed of in an environmental-
ly correct manner.
Do not dispose of eBikes and their components into house-
hold waste!
Only for EC countries:
According to the European Guideline
2012/19/EU, electrical devices/tools that
are no longer usable, and according to the
European Guideline 2006/66/EC, defective
or used battery packs/batteries, must be
collected separately and disposed of in an
environmentally correct manner.
The integrated battery pack in the on-board computer may
only be removed for disposal. Opening the housing shell can
destroy the on-board computer.
Please return battery packs and on-board computers that are
no longer usable to an authorised bicycle dealer.
Li-ion:
Please observe the instructions in sec-
tion "Transport", page English–12.
Subject to change without notice.
English–12
0 276 001 SPN | (3.7.15)