Weekly Maintenance; Monthly Maintenance; Daily Maintenance Tasks - CASTLE HPS10IC Manuel De L'utilisateur

WEEKLY MAINTENANCE

In addition to daily maintenance tasks, use an ash vacuum to clean
the inside of the firebox.
Remove the firepot from the pot holder and vacuum beneath.
Be sure to remove any ash from the incoming ignitor tube. SEE
FIGURE 35.

MONTHLY MAINTENANCE

In addition to daily and weekly maintenance tasks, the lower
exhaust chamber's cover plate should be removed and vacuumed
thoroughly. SEE FIGURE 36. This may require a hose adapter
to reach inside the chamber. This should be done monthly, or
with every 2-3 tons of fuel burned.
IMPORTANT NOTE: A HOLE SHOULD BE CUT IN THE GASKET
USING A UTILITY KNIFE TO ACCESS THE CHAMBER. THIS
WILL ALLOW YOU TO REUSE THE GASKET.
BI-MONTHLY (OR EVERY 2-3 TONS OF FUEL)
Remove and clean the exhaust venting.
Remove and clean the combustion motor, housing and impellers.
SEE FIGURE 37.
Figure 35: Remove ash from ignitor tube (underneath firepot)
32
Figure 36: Remove lower exhaust chamber's cover plate and clean
Figure 37: Remove combustion motor and clean
Check for parts online at www.castlestoves.com or call 800-345-6007 M-F 8-5 CST
Operator's Manual
HPS10IC Pellet Stove