Operation; Safety Instructions For Daily Use; Chassis - Denios Secu EX Mode D'emploi

6

Operation

6.1

Safety instructions for daily use

Always observe the following safety instructions so that dangerous situations and accidents may be avoided.
Lifting drums for transport
Lift drums a maximum of 100 mm over the forks for transport.
Setting drums down in high storage locations
Position the drum lifter as close as possible to the storage location.
WARNING
Impact from falling load.
Falling loads can cause severe injuries or death.
Ensure sufficient distance from suspended or lifted loads.
g
Only lift the drum when it is directly in front of the storage location. Then move the drum lifter very slowly and carefully
to the storage location. Only lower the drum when you are absolutely sure that the drum is going to be positioned se-
curely, completely on the storage location.
Check the castors before each use.
g
CAUTION! Dirty castors prevent the conduction of static electricity. Differences in
potential and sparks may be created. Clean dirty castors.
Always apply all the brakes [} 5 7]
g
Check the drum lifter for damage before each use.
g
NOTICE! If damage is present, the lifter may break. Remove the drum lifter from service.
Only use the drum lifter when there is no one in front of or near the drum lifter.
g
Always push/pull the drum lifter using both handles.
g
Keep sufficient distance from objects as sparks may be caused if you hit anything (if in any doubt, only use with a
g
banksman).
Do not exceed walking speed (3.6 km/h).
g
Do not cross thresholds, especially when a drum is on board.
g
Avoid sudden changes in direction.
g
Avoid swinging or oscillation of the drum lifter.
g
Never leave the drum lifter with a lifted or gripped drum on board.
g
After use store the drum lifter outside an Ex zone.
g
Turn the main switch to the OFF position if the drum lifter is not going to be used.
g
6.2

Chassis

The user controls on the chassis are used to lift and lower the gripped drum and to apply the brakes so the drum lifter
cannot roll away.
241109_Secu-Ex_004_INT
if the drum lifter is not going to be moved.
Safety instructions for daily use
Operation
55 / 144