Lubrication; Important - NSS CHARGER 2717 AB Instructions D'origine

Monthly Maintenance
(Every 100 Hours)
Verify that all daily and weekly maintenance has
been performed.
Equalize your batteries (Flooded only).
The batteries should be equalized once every 30 days
for maximum battery runtime and life.
To equalize the batteries:
 Plug in the charger, and fully charge the batteries
(until the green 100% LED is on continuously).
 Unplug the charger from the wall outlet, then plug it
back in.
 The charger will run for 2hrs, holding the batteries at
a constant voltage, and equalizing each cell.
 THIS STEP IS ESPECIALLY IMPORTANT IF YOU
PRACTICE OPPORTUNITY
CHARGING.
 Check the Battery Tray Drain Hose for liquid level on
a monthly basis.
 Spilled liquids from the battery compartment area are
collected in a tray under the batteries. The tray can be
drained using the hose at the right rear of the machine
as shown above.
 IMPORTANT: Drain all liquids into an approved
container and dispose of according to your local and
federal regulations.
 Inspect the machine components for wear, loose
fasteners, or damage. Pay special attention to all
pivot points and moving parts.
 Call an authorized NSS service center for repairs.
90 Day Maintenance
(Every 300 Hours)
Verify that all daily, weekly and monthly
maintenance has been performed.

Lubrication

 Lubricate the caster with an industrial grade bearing
grease. Failure to lubricate casters will cause the
machine to maneuver with difficulty and premature
failure of the caster will result.
 Lubricate all moving parts as required with a small
amount of grease.
 DO NOT lubricate the Gas Spring shaft, it does not
require lubrication as it is self lubricating.