Important Electrical Information; Parts List; Optional Extras - Earlex SPRAY STATION HV5500 Mode D'emploi

L1325_5500_0311.qxd:Layout 2
SAFETY OPERATING INSTRUCTIONS
WARNING! FIRE AND EXPLOSION HAZARD
CAUTION: TO REDUCE THE RISK OF ELECTRIC SHOCK
OR INJURY, DO NOT EXPOSE TO RAIN, STORE INDOORS.
G
The substances used with this spray applicator (paint, thinners etc)
may contain hazardous, harmful, explosive or corrosive materials.
G
ALWAYS COMPLY WITH THE SAFETY INSTRUCTIONS ISSUED
WITH THIS PRODUCT AND THE MATERIAL BEING USED.
Your Spray Station must only be used with paints and solvents that
have a suitable flash point for spraying. If in doubt, consult the paint
G
or solvent manufacturer's data.
Always ensure there is adequate ventilation when spraying.
G
NEVER spray near an open flame, including an appliance pilot flame.
G
NEVER smoke when spraying.
G
Always disconnect the unit from the power supply when cleaning the
spray applicator.
G
Always ensure the spray area is safe and free from all debris that may
present a fire or trip hazard.
G
NEVER, under any circumstances, point the spray gun at another
G person or animal. In the event of injury occurring, seek expert medical
advice immediately.

IMPORTANT ELECTRICAL INFORMATION

EXTENSION CORDS
Your Earlex Spray Station is supplied with a power cord that is 6 feet long. Make sure your extension cord is in good condition. When using an
extension cord, be sure to use one heavy enough to carry the current your product will draw. For lengths between 0 feet and 50 feet, 18 AWG
extension cords should be used.
DOUBLE INSULATED APPLIANCE
This is a double insulated appliance and as such, does not require three-way grounding. This product is equipped with a polarized alternating current
line plug (a plug having one blade wider than the other) and does not require a grounding adapter. This plug will fit into the power outlet only one way.
This is a safety feature.
If you are unable to insert the plug fully into the outlet, try reversing the plug. If the plug should still fail to fit, contact a
qualified electrician to replace the obsolete or damaged outlet. Do not defeat the safety purpose of the polarized plug.

PARTS LIST

Key Description
1. Air cap ring
2. Air cap
3. Air distributor plate sssy
4. Fluid tip, 0.08"
5. Fluid tip seal
6. Pivot screw
7. Washer
8. Main body assy
9. Fluid needle 0.08"
10. Adaptor
11. Spring
12. Adjusting screw
13. Pivot
14. Air feed tube
15. Gland nut

OPTIONAL EXTRAS

Needles and fluid tips of different sizes can be obtained as sets under the following accessory numbers. Please call our toll free helpline to order these
on 888-783-2612.
0.04"/ 1.0mm dia fluid tip, needle & seal
0.06"/ 1.5mm dia fluid tip, needle & seal
7/3/11 17:00 Page 5
The following parts are available from Earlex Inc. Please call our toll free helpline: 888-783-2612
Part No
L0151
L0152
L0162
L0157
L0159
L0179
L0195
L0180
L0166
L0174
L0175
L0176
L0178
L0182
L0173
HV5ACC10USR
HV5ACC15USR
Questions? Call toll free: 888-783-2612
NEVER allow children or unauthorised users to operate or play with
the spray equipment. This equipment is for professional use only.
G
Always read the paint manufacturer's thinning instructions before use.
G
Always wear the correct protective face mask when spraying. We also
recommend wearing gloves, goggles and overalls.
G
After every use ensure that you clean the spray gun thoroughly and
G grease the gland washer.
Use only genuine manufacturer replacement parts.
G
Only use the spray equipment as detailed in these instructions.
G
Do not use the air hose or power cord to pull the HVLP unit.
G
Check the hose, hose connectors and power cord daily. Any worn or
damaged parts should be replaced immediately.
G
This appliance is recommended for household use only.
G
This appliance is not intended for use by persons (including children)
G with reduced physical, sensory or mental capabilities, or lack of
experience and knowledge, unless they have been given supervision
or instruction concerning use of the appliance by a person
responsible for their safety.
Key Description
16. Gland washer (2 pcs)
17. Paint container
18. Centre bolt nut
19. Gasket
20. Lid assy
21. Shim
22. Clamp lever
23. Yoke
24. Centre bolt & pick up tube assy
25. Operating lever
26. Viscosity cup
27. Spanner
28. Filter (not shown)
29. Hose 13ft
30. Hose clip
0.08"/ 2.0mm dia fluid tip, needle & seal
0.10"/ 2.5mm dia fluid tip, needle & seal
5
MAINS
SWITCH
SHOWN IN
OFF POSI-
TION
Part No
L0168
L0190
L0189
L0188
L0187
L0186
L0185
L0184
L0183
L0177
SG243
L0191
L0058
L1107
L1289
HV5ACC20USR
HV5ACC25USR