Publicité
Liens rapides
CHOP HOUSE
BROILERS
MODEL
VST4B
ML-136590
For additional information on Vulcan-Hart or to locate an authorized parts
and service provider in your area, visit our website at www.vulcanhart.com
VULCAN-HART
DIVISION OF ITW FOOD EQUIPMENT GROUP, LLC
WWW.VULCANHART.COM
All manuals and user guides at all-guides.com
INSTALLATION &
OPERATION MANUAL
3600 NORTH POINT BLVD.
BALTIMORE, MD 21222
F-35684 (5-07)
Publicité
Manuels Connexes pour Vulcan VST4B
Sommaire des Matières pour Vulcan VST4B
- Page 1 CHOP HOUSE BROILERS MODEL VST4B ML-136590 For additional information on Vulcan-Hart or to locate an authorized parts and service provider in your area, visit our website at www.vulcanhart.com VULCAN-HART 3600 NORTH POINT BLVD. DIVISION OF ITW FOOD EQUIPMENT GROUP, LLC BALTIMORE, MD 21222 WWW.VULCANHART.COM...
- Page 2 CAUSE PROPERTY DAMAGE, INJURY OR DEATH. READ THE INSTALLATION, OPERATING AND MAINTENANCE INSTRUCTIONS THOROUGHLY BEFORE INSTALLING OR SERVICING THIS EQUIPMENT. IN THE EVENT OF A POWER FAILURE, DO NOT ATTEMPT TO OPERATE THIS DEVICE. — 2 — © VULCAN-HART, 2007...
- Page 3 All manuals and user guides at all-guides.com TABLE OF CONTENTS INTRODUCTION ..........................4 GENERAL ........................... 4 UNPACKING ..........................4 INSTALLATION .......................... 4 LOCATION ..........................4 CLEARANCES ........................... 4 INSTALLATION CODES AND STANDARDS ................4 LEG STAND ASSEMBLY INSTRUCTIONS ................5 Required Tools ........................
- Page 4 0 inches 0 inches Model Number BTU/hr Input of Burners Rating INSTALLATION CODES VST4B 3 @ 45,000 ea. 135,000 AND STANDARDS The broiler must be installed in accordance with the following: UNPACKING In the United States of America: Immediately after unpacking, check for possible shipping damage.
- Page 5 All manuals and user guides at all-guides.com LEG STAND ASSEMBLY 5. Install the rear non-locking casters into INSTRUCTIONS the remaining two (2) leg assemblies. Required Tools Tighten nut 7/16" Socket Philips Head Screw Driver 13/16" Open End Wrench Screw assembly Figure 3 Lock washer...
- Page 6 All manuals and user guides at all-guides.com 2. Install two (2) hex head bolts per leg assembly to secure broiler body onto leg stand (Fig. 5). (Apply lock-tight to bolt threads.) Hex-head Bolts Figure 6 Figure 5 GRIDDLE PLATE INSTALLATION CASTER-EQUIPPED BROILERS Put the griddle plate on top of the broiler.
- Page 7 All manuals and user guides at all-guides.com Install the regulator as close to the broiler on VENTILATION HOOD the gas supply line as possible. Make sure The broiler should be installed under a suitable that the arrow on the underside of the regulator ventilation hood.
- Page 8 All manuals and user guides at all-guides.com OPERATION WARNING: THE BROILER AND ITS The broiler is a free vented appliance. All PARTS ARE HOT. USE products of combustion and the heat generated CARE WHEN OPERATING, by the burners pass through the grates. When CLEANING, OR SERVICING meat is placed on the grates, this blocks the THE BROILER.
- Page 9 All manuals and user guides at all-guides.com PREHEATING THE BROILER Air Shutter Adjustment Allow the broiler to preheat for 30 minutes. All burner air shutters are adjusted at the plant Note that grease runs forward and drops into but may need to be readjusted depending on the trough at the front of the broiler before gas mixtures and altitudes at each location.
- Page 10 All manuals and user guides at all-guides.com CLEANING Avoid rubbing with steel pads, wire brushes or scrapers that can leave iron deposits on stainless Broiler Grate steel. Instead, use plastic scouring pads or soft cloths. For stubborn stains, always rub parallel Scrape grate thoroughly after each use so to the polish lines or with the grain.
- Page 11 WARNING: THE BROILER AND ITS PARTS ARE HOT. USE To obtain service and parts information CARE WHEN OPERATING, concerning this model, contact Vulcan-Hart CLEANING, OR SERVICING or refer to our website: www.vulcanhart.com THE BROILER. for a complete listing of Authorized Service and Parts depots.
- Page 12 All manuals and user guides at all-guides.com F-35684 (5-07) — 12 — PRINTED IN U.S.A.
- Page 13 All manuals and user guides at all-guides.com...
- Page 14 All manuals and user guides at all-guides.com...
- Page 15 All manuals and user guides at all-guides.com...
- Page 16 All manuals and user guides at all-guides.com...
- Page 17 All manuals and user guides at all-guides.com...
- Page 18 All manuals and user guides at all-guides.com...
- Page 19 All manuals and user guides at all-guides.com...
- Page 20 All manuals and user guides at all-guides.com...
- Page 21 All manuals and user guides at all-guides.com...
- Page 22 All manuals and user guides at all-guides.com...
- Page 23 All manuals and user guides at all-guides.com...
- Page 24 All manuals and user guides at all-guides.com...