Step 7: Install Drain; Step 8: Install Saddle Valve - Honeywell Home HE120 Instructions D'installation

STEP 7: INSTALL DRAIN

CAUTION
Water Hazard.
Can result in water damage to property.
Install overflow drain in applications where water
damage can result from Float Valve failure.
1. Slide the 1/2 in. Overflow Clamp over the 3/8 in.
inside diameter, 1/2 in. outside diameter Overflow
Tube.
See Fig. 30.
2. Push the Overflow Tube over the Drain Fitting.
3. Hand-tighten the Clamp around the Overflow Tube
and the Drain Fitting.
4. Fasten the Overflow Tube (can use duct tape) along
the route to the drain to prevent movement and
ensure downward slope.
5. Cut Overflow Tube to length so the tubing termi-
nates at the drain or bucket using a utility knife.
Fig. 30. Installing overflow tube.
IMPORTANT
Overflow Tube must follow downward slope from
Humidifier to drain for correct draining.
STEP 8: INSTALL SADDLE
VALVE
CAUTION
Chemical Hazard.
Can cause personal injury or equipment damage.
Do not use any line connected to an air conditioner.
Do not use gas line.
IMPORTANT
NOTE: This saddle valve can be used with either copper
Copper Pipe:
1. Shut off the water. (Either hot or cold water and
either hard or softened water can be used in the
Humidifier.)
2. Turn handle counter clockwise until piercing lance is
below the rubber gasket. See Fig. 31.
Fig. 31. Positioning Saddle Valve for installation with
M20177
3. Assemble saddle valve over copper tube using
#10 x 1-3/4 in. machine screws. See Fig. 32.
13
HE120 BY-PASS DRUM HUMIDIFIER
Do not turn handle before or while installing the
saddle valve. Be sure the piercing lance does not
protrude beyond the rubber gasket. Failure to do
this may damage piercing needle.
To prevent debris from clogging the Float Valve, do
not install the saddle valve with the handle point-
ing toward the floor.
or steel/brass pipe. Please refer to the correct
instructions for your application.
LANCE
BELOW
GASKET
Copper Pipe.
WATER LINE
Fig. 32. Installing Saddle Valve.
M13631
SCREW DRIVER
M20175
69-1860EF—02