Technical Data; Cleaning And Maintenance - Royal Catering RCWB-550I Manuel D'utilisation

The operation manual must be reviewed.
Never dispose of electrical equipment together
with household waste.
This machine conforms to CE declarations.
Attention! Hot surface may cause burns.
PLEASE NOTE! Drawings in this manual are for
illustration purposes only and in some details it may
differ from the actual machine.
The original operation manual is in German. Other language
versions are translations from German.
USER MANUAL
SAFETY INSTRUCTIONS
General safety information for the use of electrical devices:
To avoid injury from fire or electric shock, please ensure
compliance with safety instructions when using this device.
Please read the instructions carefully and make sure that
you have understood them well. Keep the manual near the
equipment to be able to read it at any time. Always use
current sources connected to the ground and providing the
necessary voltage (indicated on the label on the device). If
you have any doubt, let an electrician check that your outlet
is properly grounded. Never use a damaged power cable.
Do not open the unit in damp or wet environment, or if your
hands or body are damp or wet. Protect the unit from solar
radiation. Use the device in a protected location to avoid
damaging the equipment or endangering others. Make sure
the device is able to cool and avoid placing it too close to
other devices that produce heat. Before cleaning, disconnect
it from the power source. Use a soft damp cloth for cleaning.
Avoid using detergents and make sure that no liquid enters
the unit. No internal element of this device needs to be
maintained by the user. Opening the device without our
approval leads to a loss of warranty!
SAFETY GUIDELINES
1. Please read and understand these instructions
carefully before operating the device! Please observe
the safety guidelines carefully in order to prevent
damages through improper use!
2. Please keep this manual available for future
reference. If this device is passed on to third parties,
the manual must be passed on with it.
3. Only use this device indoors and for its intended use.
4. We do not offer any warranty for damages resulting
from improper use or incorrect operation.
5. Before the first use, please check whether the main
voltage type and current comply with the indicated
data on the type plate.
6. This device is not intended to be used by persons
(including children) with limited physical, sensory
or mental aptitude or lack of experience and/or
knowledge, unless they are supervised by a person
responsible for their safety or have received
instruction from this person as to how the device is
used.
7. ELECTRIC SHOCK HAZARD! Do not attempt to repair
the unit yourself. In case of device failures, repairs
must be done by qualified experts.
8. Please check main plug and power cable regularly. If
the power cable for this device is damaged, it has to
6
U S E R M A N U A L
be replaced by the manufacturer or its customer
service or another qualified person in order to
prevent hazards.
9. Prevent damages to the power cable by avoiding
squeezing or bending it or rubbing it on sharp
edges. Also keep the power cable away from hot
surfaces and open flames.
10. ATTENTION! DANGER TO LIFE! While cleaning, never
immerse the device in water or other liquids.
11. Under no circumstances should the housing be
opened.
12. Do not place kitchen utensils towels, paper etc. on
the lamp frame.

TECHNICAL DATA

Product name Infrared Food Warmer
Model RCWB-550I
Rated voltage [V] 230~
Frequency [Hz] 50
Rated power [W] 2 x 275
Temperature range* [°C] 40 – 70
Food pan dimensions [mm] 530x325x65
Weight [kg] 2,7
* depending on the height set for the bain-marie/food pan
and the height set for the lamps
SCOPE OF APPLICATION
The infrared food warmer is designed to keep food warm.
Do not use the infrared food warmer for:
• heating liquids or flammable materials
• heating premises
• drying wet items (e.g. clothes, boxes, etc.)
The user is liable for any damage resulting from non
-intended use of the device!
BERORE THE FIRST USE
Upon receipt of the goods, check the packaging for integrity
and open it. If the packaging is damaged, please contact
your transport company and distributor within 3 days, and
document the damages as detailed as possible. Do not turn
the package upside down! When transporting the package,
please ensure that it is kept horizontal and stable.
DISPOSING OF PACKAGING
Please keep all packaging materials (cardboard, plastic
tapes and Styrofoam), so that in case of a problem, the
device can be sent back to the service centre in accurate
condition!
INSTALLING THE APPLIANCE
APPLIANCE LOCATION
The temperature of environment must not be higher than
45°C and the relative humidity should be less than 85%.
Ensure good ventilation in the room in which the device
is to be used. The distance between the back of the chain
toaster and the wall should be at least 20 cm, minimum
distance between the sides of the device and the walls
should be at least 10 cm on each side and 35 cm between
the top of the device and the ceiling.
Rev. 06.09.2017
Keep the device away from hot surfaces. Operate the device
on flat, stable, clean, refractory and dry surfaces out of the
reach of children and people with mental disabilities. Install
the device making sure that constant access to the main
plug is ensured. The power cord connected to the appliance
must be properly grounded and correspond to the technical
details. Before the first use, remove all elements and clean
them along with the entire device!
DEVICE OPERATION – BASIC PRINCIPLES
3
1
2
4
5
6
9
7
1. lamp frame
2. infrared warmer
3. power cable
4. ON/OFF switch
5. lamp frame with adjustable arm clamping bolt
6. adjustable arm
7. adjustable arm height control
8. base
9. gastronorm container
Place warm food in the gastronorm container and then
activate the warmer using the ON/OFF switch. After use
turn the device off using the ON/OFF switch.
ATTENTION! When in use the lamps may be hot – do not
touch with bare hands – risk of burning!
ATTENTION! The gastronorm container heats up when in
use, always use protective kitchen gloves or towels when
handling.
ATTENTION! Do not use sharp or metal cutlery to stir foods
in the gastronorm container. Use appropriate kitchen
utensils for stirring.
Rev. 06.09.2017
ASSEMBLY/DISASSEMBLY OF THE DEVICE'S ELEMENTS
Place the base on a flat and stable surface, insert the
adjustable arm into the base and tighten the clamping
nut. Then insert the lamp frame into the adjustable arm
and tighten the nut as much as possible. Once the arm is
assembled, adjust its height. To do that, loosen the bottom
bolt, set the required height and tighten the nut.
TRANSPORTATION AND STORAGE
Shaking, crashing and turning upside down of the device
8
should be prevented when transporting it. Store it in
a properly ventilated location with dry air and without any
corrosive gas.

CLEANING AND MAINTENANCE

• Before cleaning, wait for the lamps and the food pot
to cool down. Otherwise there is a risk of burning.
• Always unplug the device before cleaning it.
• Use cleaner without corrosive substances to clean
surface.
• Dry all parts well after cleaning before the device is
used again.
• Store the unit in a dry, cool place, free from moisture
and direct exposure to sunlight.
CHECK REGULARLY THE DEVICE
Check regularly whether the device is damaged. If it should
be damaged, please stop using it immediately and contact
your customer service to solve the problem.
What to do in case of a problem?
Please contact your customer service and prepare the
following information:
• Invoice number and serial number (the latter is to be
found on the technical:
• • If relevant, a picture of the damaged, broken or
defective part.
• • It will be easier for your customer service clerk to
determine the source of the problem if you give
a detailed and precise description of the matter.
Avoid ambiguous formulations like "the device does
not heat", which may mean either that it does not
heat enough or that it does not heat at all. The more
detailed your information, the better the customer
service will be able to solve your problem rapidly and
efficiently!
CAUTION: Never open the device without the authorization
of your customer service. This can lead to a loss of warranty!
7