Osmosis OSMOSOR 5E Mode D'emploi page 21

6. MAlNTENANCE
The osmoser 5 stages reverse osmosis equipment requires low maintenance.
- Replace the prefilters once every 12 months to assure a good system feeding and a good removal of inlet
water chlorine. At the same time this will prevent excessive dirt from limiting water flow at the membrane.
- The mineralizing postfilter should be replaced every 12 months, coinciding with the prefilter replacement.
- The osmosis membranes must be changed when the dissolved salts reduction is below 80 %. Membranes
lifeti me i s af fected by th e w ate r charac teristic s ( pH , har dness, iron , chlori ne , etc.).
- Sediment and charcoal cartridges should be changed every 12 months.
- For a sanitary warranty , the osmoser must be periodically hygienized , by cleaning the elements which
comprise the filtration system.
- The equipment hygienisation must be done by an Authorized Technical Service, and following all instructions
that come with the cleaning products.
Caution: Even if the entry valve is closed, the vessels containing the filters contain an important
amount of water. Please take the precaution of having a container for its emptying in order to
avoid a water spillage.
Note: f the prefilter or postfilter are replaced, it is not imperative to replace the rest.
f the reverse osmosis membrane is replaced, the sediment prefilter, the activated charcoal filter and
the remineralizer postfilter must also be replaced.
7. PROBLEM SOLVlNG GUlDE
ANOMALY
There is no water output
There is output of
bad flavoured water
The pump operates
continuosly
CAUSE
- s the equipment properly
connected to the electric supply?
- s the hydraulic system
properly connected?
- Check that there is sufficient
supply of water
- The membrane is obstructed
- Has the proper maintenance
been done?
- Are there any leaks in the
system?
- The accumulation tank has
been filled?
SOLUTlON
- Check the electrical connections
-Check that there are no water leaks
in the installation
- Check that the faucet has been
properly installed
- Open any faucet to test it
- Call the technical service to replace
the membrane
- Call the technical service to
do the maintenance
- f there are leaks, call the technical
service
- Wait for at least one hour before
establishing the failure
8