Nilfisk Advance SR 1800C B-D Manuel D'utilisation page 63

PROBLEM
Excessive broom wear
Excessive/modified broom noise
Main broom fails to turn
Main broom fails to lift/lower (hydraulic model)
Side broom fails to turn
Side broom fails to lift/lower
Faulty turn signals
Brake lights off
Faulty running lights
Low beam off
High beam off
Horn off
Battery fails to keep rated charge
Battery runs out quickly
33014817(2)2006-06 A
CAUSE
Heavy print
Surface to be cleaned too abrasive
Materials tangled around the broom
No pressure to hydraulic motor
Locked distributor
Hydraulic motor failure
Locked linkage
No pressure to cylinder
Worn cylinder gasket
Locked distributor
No pressure to hydraulic motor
Locked distributor
Locked distributor (hydraulic model)
Worn cylinder gaskets (hydraulic model)
Cylinder failure
Blown fuse
Blown bulbs
Blown flashing device
Open combination switch
Open warning switch
Blown fuse
Blown bulbs
Open stop switch
Blown fuses
Blown bulbs
Open combination switch
Open dimmer switch
Blown fuses
Blown bulbs
Open combination switch
Open dimmer switch
Blown light relay
Blown bulbs
Open combination switch
Open dimmer switch
Blown light relay
Open combination switch
Blown fuse
Horn filled with water
Faulty horn
No fluid in the battery
Shorted battery cell
Overloaded motors
Loose battery terminals
Insufficient charge time setting
Spent battery cells
USER MANUAL
REMEDY
Use minimum print width
Remove
Check pump pressure (replace pump)
Unlock distributor
Replace motor
Check linkage
Check pump pressure (replace pump)
Replace gasket
Unlock distributor
Check pump pressure (replace pump)
Check/replace motor
Check distributor
Unlock distributor
Replace gaskets
Check cylinder/replace gaskets
Replace fuse
Replace bulbs
Replace flashing device
Replace combination switch
Replace switch
Replace fuse
Replace bulbs
Replace switch
Replace fuse
Replace bulbs
Replace combination switch
Replace dimmer switch
Replace fuse
Replace bulbs
Replace combination switch
Replace dimmer switch
Replace relay
Replace bulbs
Replace combination switch
Replace dimmer switch
Replace relay
Replace combination switch
Replace fuse
Overhaul horn
Replace horn
Restore level
Replace battery
Check motor absorption
Check and tighten
Set correct charge time
Replace battery
13