LGB 99 6001-4 Sound Instructions De Service page 17

ATTENTION! After extended opera-
tion, this model may leave carbon
dust or other debris around the track.
This dust and debris can stain carpet
and other materials. Consider this
when setting up your layout. Ernst
Paul Lehmann Patentwerk and LGB
of America are not liable for any
damages.
SERVICE
Do-It-Yourself Service Levels
Level - Beginner
Level - Intermediate
Level - Advanced
ATTENTION! Improper service will
void your warranty. For quality ser-
vice, contact your authorized retailer
or an LGB factory service station
(see Authorized Service).
Hint: Additional expert instructions
for many LGB products are available
at www.lgb.com.
Lubrication
The axle bearings and the side rod
ends should be lubricated occasion-
ally with a small amount of LGB
Maintenance Oil (50019).
Cleaning
This model can be cleaned externally
using a mild detergent and gentle
stream of water. Do not immerse this
model.
Replacing the light bulbs
Lights (front/rear): Remove the ring
around the lantern lens. Carefully pry
the lens away from the lantern. Using
tweezers, remove and replace the
bulb. Reassemble.
Cab light: Using tweezers, remove
and replace the bulb.
Replacing the smoke generator
- Pull the safety cover out of the
smoke stack (Fig. 5).
- Use pliers or tweezers to pull the
old smoke generator out of the
stack (Fig. 6).
- Cut the wires to the old generator
and attach them to the replacement
generator.
- Insulate the connections and push
the replacement generator into the
stack (Fig. 7).
- Reassemble.
Replacing the traction tire
- Remove the hex nut on the rear
drive wheel with the traction tire.
- Remove the side rods from the
drive wheel.
- Use a small, straight-blade screw-
driver to replace the traction tire:
- Pry the old traction tire out of the
wheel groove.
- Gently insert the new traction tire
into the wheel groove.
- Make sure that the traction tire is
seated properly in the wheel
groove.
- Reassemble.
Maintenance parts
50010 Smoke and Cleaning Fluid
50019 Maintenance Oil
51020 Gear Lubricant
62201 Standard Motor with Short
Shaft
63120 Brushes, Assembled,
14 mm and 16 mm, 8 pieces
(2 packages needed)
63218 Standard Pick-Up Shoes,
2 pieces
65853 Smoke Generator, 5V
68511 Plug-In Bulb, Clear, 5V,
10 pieces
69104 Traction Tire, 37.5 mm,
10 pieces
19