Table Des Matières; Important Safety Instructions - Pentair Myers MSK60 Installation Et Manuel De L'opérateur

Safety
Contents
Important Safety Instructions . . . . . . . . . . . . . . . . . . . . . . .2
Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
Replacing diaphragm switch . . . . . . . . . . . . . . . . . . . . . . . . . 4
Checking motor stator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Ground check . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Oil fill . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
Repair Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8
Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9
Product Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . .10

Important Safety Instructions

SAVE THESE INSTRUCTIONS - This manual contains
important instructions that should be followed during
installation, operation, and maintenance of the product.
Save this manual for future reference.
This is the safety alert symbol. When you see this
symbol on your pump or in this manual, look for one of
the following signal words and be alert to the potential
for personal injury!
indicates a hazard which, if not avoided, will
result in death or serious injury.
indicates a hazard which, if not avoided,
could result in death or serious injury.
indicates a hazard which, if not avoided,
could result in minor or moderate injury.
NOTICE addresses practices not related to personal injury.
The manufacturer cannot anticipate every possible
circumstance that might involve a hazard. The warnings
in this manual, and the tags and decals affixed to the unit
are, therefore, not all-inclusive. If you use a procedure
or operating technique that the manufacturer does not
specifically recommend, you must satisfy yourself that it
is safe for you and others. You must also make sure that
the procedure or operating technique that you choose
does not render the system unsafe.
Electrically powered sewage pumps normally give many
years of trouble-free service when correctly installed,
maintained, and used. However, unusual circumstances
(interruption of power to the pump, large solids in
the sump, flooding that exceeds the pump's capacity,
electrical or mechanical failure in the pump, etc.) may
prevent your pump from functioning normally. To prevent
possible damage, consult your dealer about installing
a secondary sewage pump or a high water alarm. See
Troubleshooting in this manual for information about
common sewage pump problems and remedies. For
more information, see your retailer, call HYDROMATIC ®
customer service at 1-888-957-8677 or visit our web site
at hydromatic.com.
Hazardous voltage - risk of electrical
shock. Shock can cause serious injury or death.
Failure to follow the warnings below can result in fatal
electric shock.
Burn Hazard. Motors can operate at high
temperatures. Do not touch an operating motor. To do so
can cause personal injury.
Risk of flooding. If a flexible discharge hose
is used, pump may move around in sump when motor
starts. If it moves far enough so that the switch hits the
side of sump, the switch may stick and prevent the pump
from starting. Make sure the pump is secured so it cannot
move around in the sump.
Hazardous pressure and gas - risk of
explosion and personal injury. Failure to follow the
warnings that follow can result in personal injury.
1. If your basement has water or moisture on the floor,
do not walk on the wet area until all the power
has been turned off. If the shut-off box is in the
basement, call the electric company or the hydro
authority to shut off the service to the house, or call
your local fire department for instructions. Do not
handle the pump or pump motor with wet hands or
when standing on wet or damp surfaces.2.
Connect only to a properly grounded receptacle.
3. All wiring should be performed by a
qualified electrician.
4. Protect the electrical cord from sharp objects, hot
surfaces, oils, and chemicals. Observe the Cord Lift
Warning shown below.
2