Extraordinary Maintenance - Cattani TURBO HP Manuel D'utilisation

Extraordinary maintenance

Extraordinary maintenance must be entrusted to a trained techni-
cian in possession of original spare parts:
- pay special attention to danger signals. Use goggles, gloves
and disposable overalls for personal protection;
- check that routine maintenance has been duly carried out
and make sure that Magnolia products are used;
- before any intervention carry out a series of washes with
Puli-Jet plus disinfectant, then wait 60 minutes for a com-
plete disinfectant action. For more safety, it is advisable to
disinfect the evening before the intervention;
- every 6/9 months check the condensers effi ciency.
• Recommended every 12 months:
- check the aspirator noise level according to the regulation
3047 (E) (see the "General running data" at pages 14-15);
- remove dust from the circuit AC 80 inside electronic compo-
nents using a blast of dry air not exceeding 2 bar pressure.
By means of a 6 bar blast of air clean also the small holes
on the frontal cover of the aspirating unit (15);
- check the conditions of plastic hoses, in particular the hoses
under pressure connecting the centrifugal separator (11)
and the Hydrocyclone ISO. We suggest to replace these
hoses every 12-18 months.
• Recommended every 18-24 months:
- check the working conditions of the centrifugal separator
(11) and re-circulation valve (14).
• Recommended every 10.000 working hours:
- every time a component containing a rubber part ("O" ring,
gasket or seal) is disassembled, replace the rubber part;
- replace the motors bearings;
- where routine maintenance is not carried out properly or
unsuitable products are used, train the staff and inform the
person in charge.
15
14
11
22