Ashley AW1120E-P Manuel D'instructions Et D'utilisation Du Propriétaire
  1. Manuels
  2. Marques
  3. Ashley Manuels
  4. Poêles à granulés
  5. AW1120E-P
  6. Manuel d'instructions et d'utilisation du propriétaire
Ashley AW1120E-P Manuel D'instructions Et D'utilisation Du Propriétaire

Ashley AW1120E-P Manuel D'instructions Et D'utilisation Du Propriétaire

Masquer les pouces Voir aussi pour AW1120E-P:
Table des Matières

Liens rapides

Télécharger ce manuel
Owner's Instruction and Operation Manual
Model Numbers:
AW1120E-P • AW1120E-BP
AW1120E-L • AW1120E-BL
Report Number: F19-473
Tested Per EPA Methods ALT-125, ASTM
E2515, ASTM E3053 and CSA B415
Certified to UL 1482-2011 (R2015) and
ULC-S627-00-REV1
Mobile home approved USA & Canada
* All Pictures In This Manual Are For Illustrative Purposes Only. Actual Product May Vary.
Save These Instructions In A Safe Place For Future Reference.
SAFETY NOTICE: If this heater is not properly installed, a house fire may result.
For your safety, follow the installation instructions. Never use make-shift
compromises during the installation of this heater. Contact local building or
fire officials about permits, restrictions and installation requirements in your
area. NEVER OPERATE THIS PRODUCT WHILE UNATTENDED.
CAUTION! Please read this entire manual before you install or use your new room
heater. Failure to follow instructions may result in property damage, bodily injury,
or even death. Improper Installation Will Void Your Warranty!
U.S. Environmental Protection Agency
Certified to comply with 2020 particulate
emissions standards.
THIS MANUAL IS SUBJECT TO CHANGE WITHOUT NOTICE.
© 2021 United States Stove Company, 227 Industrial Park Rd., South Pittsburg, TN 37380
All manuals and user guides at all-guides.com
R
CALIFORNIA PROPOSITION 65 WARNING:
This product can expose you to chemicals including carbon
monoxide, which is known to the State of California to cause
cancer, birth defects, and/or other reproductive harm. For
more information, go to
www.P65warnings.ca.gov
853573H-1805K
Ph. 800-750-2723
Table des Matières
loading

Manuels Connexes pour Ashley AW1120E-P

Sommaire des Matières pour Ashley AW1120E-P

  • Page 1 All manuals and user guides at all-guides.com Owner’s Instruction and Operation Manual Model Numbers: AW1120E-P • AW1120E-BP AW1120E-L • AW1120E-BL Report Number: F19-473 Tested Per EPA Methods ALT-125, ASTM E2515, ASTM E3053 and CSA B415 Certified to UL 1482-2011 (R2015) and ULC-S627-00-REV1 Mobile home approved USA &...
  • Page 2 All manuals and user guides at all-guides.com INTRODUCTION This manual describes the installation and operation of the Ashley, AW1120E wood heater. This heater meets the 2020 U.S. Environmental Protection Agency’s cordwood emission limits for wood heaters sold after May 15, 2020. Under specific test conditions this heater has been shown to deliver heat at rates ranging from 15,196 to 40,594 Btu/hr with 1.7 g/hr and 69% efficiency.

  • Page 3: Installation Checklist

    All manuals and user guides at all-guides.com INSTALLATION CHECKLIST Your Wood Stove should be installed by a qualified installer only. An NFI qualified Installer can be found at www.nficertified.org/public/find-an-nfi-pro/ CUSTOMER SERVICE 1-800-750-2723 ext 5050 Text to 423-301-5624 Email to: Customerservice@usstove.com COMMISSIONING CHECKLIST This Checklist is to be completed in full by the qualified person who installs this unit.

  • Page 4: Tools And Materials

    All manuals and user guides at all-guides.com ASSEMBLY INSTRUCTIONS For Customer Service Call: 800-750-2723 Ext 5050 TOOLS AND MATERIALS ASH PAN ASSEMBLY You will need a drill with a 1/8” bit to install sheet metal Remove ash pan from firebox. Under the firebox, screws into connector pipe.
  • Page 5 All manuals and user guides at all-guides.com ASSEMBLY INSTRUCTIONS FIREBRICK CONFIGURATION AIR DEFLECTOR ASSEMBLY Replace the Firebrick as shown in the illustration. Use the provided screws to attach the air deflector to the rear of the unit. INSTALLATION SAFETY NOTICE •...

  • Page 6: Clearances To Combustibles

    All manuals and user guides at all-guides.com INSTALLATION FLOOR PROTECTOR • A flue pipe crossing a combustible wall must have a minimum clearance of 18” (458 mm). This heater must have a non-combustible floor protector (ember protection) installed beneath it if •...
  • Page 7 All manuals and user guides at all-guides.com INSTALLATION SECURING APPLIANCE’S ON A Your stove does not draw steadily, smoke roll-out occurs, wood burns poorly, or back-drafts occur PEDESTAL TO THE FLOOR whether or not there is combustion present. Use the designated holes to secure the unit to the floor.
  • Page 8 All manuals and user guides at all-guides.com INSTALLATION In addition to the previously detailed installation of 0.021” or 0.53 mm. It is strictly forbidden to requirements, mobile home installations must use galvanized steel. The smoke pipe should be meet the following requirements: assembled to promote the male section (crimped end) of the pipe to be faced down.

  • Page 9: Masonry Chimney

    All manuals and user guides at all-guides.com INSTALLATION Your wood stove may be hooked up with a 6” package or wall pass-through and “T” section factory-built or masonry chimney. If you are using package, firestops (where needed), insulation a factory-built chimney, it must comply with UL 103 shield, roof flashing, chimney cap, etc.
  • Page 10 All manuals and user guides at all-guides.com INSTALLATION Concrete Cap Fireclay Flue Liner With Airspace 1” Clearance with Firestop Rafter Flashing Flashing Eave Combustible Wall 1” Clearance Thimble 12” of Brick METHOD 9” (228.6 mm) Clearance to Combustible Wall Member: Using a 6” (152.4 mm) inside diameter, listed, factory-built Solid-Pak Sheathing chimney section with insulation of 1”...
  • Page 11 All manuals and user guides at all-guides.com INSTALLATION wall thimble, and cover its opening with a 24-gage plates at both ends of chimney section. Cover minimum sheet metal support. Maintain the 6” opening with and support chimney section on both (152.4 mm) space.
  • Page 12 All manuals and user guides at all-guides.com OPERATION INSTRUCTIONS NEVER OPERATE THIS PRODUCT WHILE UNATTENDED OPERATING SAFETY PRECAUTIONS CAUTIONS: HOUSE FIRE HAZARDS • NEVER OVERFIRE THIS APPLIANCE BY • DO STORE WOOD FLOOR BUILDING EXCESSIVELY HOT FIRES AS A PROTECTOR, UNDERNEATH STOVEPIPE(S) HOUSE/BUILDING FIRE MAY RESULT.
  • Page 13 All manuals and user guides at all-guides.com OPERATION INSTRUCTIONS these materials does not prohibit the use of fire the number of logs burned at a time but make sure starters made from paper, cardboard, sawdust, the temperature never rises higher than 475 °F (246 wax, and similar substances to start a fire in an °C) on a magnetic thermometer for installation on affected wood heater.

  • Page 14: Fueling Instructions

    All manuals and user guides at all-guides.com OPERATION INSTRUCTIONS fire is established a lower burn rate may be a better cordwood. NOTE: Use smaller pieces of wood during option for efficient heating. A lower burn rate slows start-up and a high burn rate to increase the stove the flow of usable heat out of the home through temperature.

  • Page 15: Blower Operation

    All manuals and user guides at all-guides.com OPERATION INSTRUCTIONS VISIBLE SMOKE setting, follow the same procedure as a medium burn for loading and initial ignition. After 5 minutes The amount of visible smoke being produced can be of burning, slowing move your air to the fully closed an effective method of determining how efficiently position.

  • Page 16: Chimney Maintenance

    All manuals and user guides at all-guides.com CHIMNEY MAINTENANCE NEVER OPERATE THIS PRODUCT WHILE UNATTENDED • Leave the air control fully open for about 5 min. CAUTION: every time you reload the stove to bring it back DO NOT OVERFIRE APPLIANCE. YOU ARE to proper operating temperatures.

  • Page 17: How To Order Repair Parts

    All manuals and user guides at all-guides.com CHIMNEY MAINTENANCE SMOKE & CO MONITORS the stores where wood stoves are sold. The glass should be washed only when cold. Burning wood naturally produces smoke and carbon monoxide(CO) emissions. CO is a poisonous GASKET CARE gas when exposed to elevated concentrations for extended periods.
  • Page 18 All manuals and user guides at all-guides.com OPTIONAL B36 BLOWER WIRING DIAGRAM DANGER: SHOCK HAZARD DISCONNECT POWER SOURCE BEFORE INSTALLATION AND WHENEVER SERVICING BLOWER ASSEMBLY. CAUTION: MOVING PARTS CAN CAUSE INJURY. DO NOT OPERATE WITH COVER REMOVED. WHITE / BLACK / BLACK / BLANC NOIR...

  • Page 19: Repair Parts

    All manuals and user guides at all-guides.com REPAIR PARTS Part# Description 29139 Air Deflector 891824 Heatshield Weldment 40292A 6” Flue Collar 88042 1/4” Rope Gasket 892292 Hearth Trim 891137 Brushed Nickel Handle 29035 Ashpan 610923 Pedestal Weldment (AW1120E-BP) 610928 Damper Weldment 610918 Access Panel 86709...
  • Page 20 All manuals and user guides at all-guides.com REPAIR PARTS Part# Description 893241-AW Complete Door Handle 40883 Medium Arched Door 88324 1” Rope Gasket 893159 Clear Glass 29227 Top Glass Retainer 29229 Side Glass Retainer 29230 Gasket Clamp 29228 Bottom Glass Retainer 892294 Hinge Pin To order parts:...

  • Page 21: Service Record

    All manuals and user guides at all-guides.com SERVICE RECORD It is recommended that your heating system is serviced regularly and that the appropriate Service Interval Record is completed. SERVICE PROVIDER Before completing the appropriate Service Record below, please ensure you have carried out the service as described in the manufacturer’s instructions.
  • Page 22 All manuals and user guides at all-guides.com NOTES © 2021 United States Stove Company...
  • Page 23 All manuals and user guides at all-guides.com NOTES © 2021 United States Stove Company...
  • Page 24 All manuals and user guides at all-guides.com...
  • Page 25 All manuals and user guides at all-guides.com...
  • Page 26 All manuals and user guides at all-guides.com...
  • Page 27 All manuals and user guides at all-guides.com...
  • Page 28 All manuals and user guides at all-guides.com...
  • Page 29 All manuals and user guides at all-guides.com...
  • Page 30 All manuals and user guides at all-guides.com...
  • Page 31 All manuals and user guides at all-guides.com...
  • Page 32 All manuals and user guides at all-guides.com...
  • Page 33 All manuals and user guides at all-guides.com...
  • Page 34 All manuals and user guides at all-guides.com...
  • Page 35 All manuals and user guides at all-guides.com...
  • Page 36 All manuals and user guides at all-guides.com...
  • Page 37 All manuals and user guides at all-guides.com...
  • Page 38 All manuals and user guides at all-guides.com...
  • Page 39 All manuals and user guides at all-guides.com...
  • Page 40 All manuals and user guides at all-guides.com...
  • Page 41 All manuals and user guides at all-guides.com...
  • Page 42 All manuals and user guides at all-guides.com...
  • Page 43 All manuals and user guides at all-guides.com...
  • Page 44 All manuals and user guides at all-guides.com...

Ce manuel est également adapté pour:

Aw1120e-bpAw1120e-lAw1120e-bl

Table des Matières