Correct Use; Dt-Mobile Easy With Adr Approval; Dt-Mobile Easy To Adr 1.1.3.1C); Inappropriate Use - CEMO DT-Mobil Easy 980l Manuel D'utilisation

GB

1.2 Correct use

The DT-Mobil Easy mobile diesel filling station is
an approved IBC (Intermediate Bulk Container)
in accordance with ADR for hazardous goods in
packaging group II + III (liquid water-polluting sub-
stances).
The filling station is intended for use at a variety of
locations outdoors.
It may only be filled or transported having under-
gone a valid inspection/check. Repeat inspection
2½ years after the date of manufacture according to
ADR 6.5.4.4.1 b) and 6.5.4.4.2.
Operating temperature range: - 10 °C to + 40 °C
Important!
i
Only a clean medium may be conveyed.
Correct use (preferably) concerns, for example,
the following liquids:
• diesel fuel.
• heating oil.
• biodiesel.

1.2.1 DT-Mobile Easy with ADR approval

In accordance with the ADR, the following
are required for the simplified transport
of dangerous goods (< 1000 points):
• labelling (sticker) of the filling station.
• requirement to equip with a fire extinguisher (2 kg)
• carriage of supporting document
(in this case, carriage paper –
observe national exemption regulations)
(no carriage paper in Germany –
exemption 18 S)
• compliance with the so-called "1000-points rule"
in accordance with table 1.1.3.6 ADR, i.e. total
quantity per transport unit < 1000 points.
» 1 l of diesel fuel = 1 point
• repeat inspection by an expert required 2½ years
after the date of manufacture. ADR approval
expires after 5 years. The filling station may still
be used after 5 years in accordance with regula-
tion ADR 1.1.3.1c (see sections 1.2.2 and 8.1).
i
Important!
It is essential to read the relevant
regulations of the ADR.
30
1.2.2 DT-Mobil Easy to ADR 1.1.3.1 c)
Identifiable on type plate without
D/BAM approval no.
In accordance with ADR 1.1.3.1 c) (called the
"craftsman regulation" in Germany), hazardous
goods may also be transported using containers
without ADR approval.
The following applies for containers without
ADR approval:
• transport only for direct use with self-filling
(i.e. approaching only one filling point and filling
not done by a third party)
• unloading of the container from the vehicle at the
place of filling is not permitted
• no tagging (stickers) required
• no requirement to equip with a fire extinguisher
• no supporting documents required
• permitted container content: max. 450 l; the
so-called "1000 points rule" also applies
(see section 1.2.1),
• no repeat testing required
• no reduction in service life.
1.2.3 Summary
The equipment is not intended for any other or
additional purpose.
For safety reasons, modifications are not
allowed to the filling station (except for the
addition of accessories specially provided
by the manufacturer – see section 6).
Correct usage also includes compliance with all
information in these operating instructions.

1.3 Inappropriate use

i
Important!
Inappropriate use also includes failure to
observe the notices in these operating
instructions.
F u r t h e r m o r e :
• non compliance with the regulations of the ADR
and prevailing national provisions.
• storage and transport of liquids other than those
stipulated under Correct use, e.g.: petrol, bio-
ethanol, chemicals, oils (lubricating, hydraulic,
plant oils).