Security Instructions - Zipper Maschinen ZI-HAEK4100 Mode D'emploi

11.2 Security instructions

Missing or non-readable security stickers have to be replaced immediately!
To avoid malfunction, machine defects and injuries, read the following security
instructions!
The locally applicable laws and regulations may specify the minimum age of the operator and limit the
use of this machine!
Use the machine only in good enough light to allow a safe operation can be guaranteed.

In tiredness, decreased concentration or under the influence of alcohol or drugs, the work on the

machine is prohibited!
Caution in slippery conditions - slip hazard - risk of injury. When working, robust and non-slip

footwear. Slides / stumble / traps are a major cause of serious injury or death.
Unauthorized persons, especially children and not trained personnel must be kept away from the

running machine!
The machine must be operated only by trained persons (knowledge and understanding of this

manual), which have no limitations of motor skills compared with conventional workers.
No other person and pets shall remain within 12m!

If you pass the machine to third, these instructions must be attached to the machine.

Before each use, the reliability of the machine is to be checked (tightness of the cutting tool, the

proper function of the throttle lever, safety switch)
Use personal safety equipment: ear protectors, safety gloves in EN 388, class 3111, safety shoes

S1, safety goggles or face protection when working with the machine!
Make sure that the device is completely and correctly assembled.

Never leave the machine running unattended! Before leaving the working area switch the machine

off and wait until the machine stops.
Switch off the machine before maintenance or adjustment.

The machine should be only during operation on solid level ground.

Neither put your hands into the in-feed and discharge chute when the machine is running.

Using your shredder only in places where it is protected from water and never use it during rain

outdoors.
Danger of burns! During the operation flow of hot exhaust gases and engine parts such as the

muffler and engine become hot.
WARNING: Gasoline is highly flammable!

Stop the engine before refuelling

Smoking and open flames are prohibited during refuelling.

Do not refuel when the engine and carburettor are still very hot.

Refuel only outdoors or in a well ventilated area.

Avoid contact with skin and clothes (fire hazard)

Check after refuelling tank cap and check for leaks.

Start the engine at least 3 meters from the tank location.

Spilled fuel is wipe immediately.

Keep the fuel in suitable containers only

Make sure the fuel does not overflow. If the fuel overflows, the engine must not be started.

Remove any dirt from the appliance and prevent any attempt at ignition until fuel fumes have
evaporated
Damaged fuel tank or other tank cap must be replaced immediately

After the operation the fuel cock must be closed (if available)

Danger of Intoxication! Only use outdoors and far from open windows and vents!

Exhaust contains poisonous carbon monoxide. The exposure can cause unconsciousness and

death.
Before the start, after the failure or shock, be sure to check the device and make sure that it is in

good condition
Change damaged parts immediately
TRANSPORT NOTES:
Switch off the engine and let cool down

Never lift or carry the machine while the engine is running

Wait till the blade are completely stopped

Secure the machine

Empty tank completely, avoid fuel spillage

To avoid damage to the device never drag but always lift correctly.

ZIPPER MASCHINEN GmbH
ZI-HAEK4100 / ZI-HAEK11000
www.Zipper-Maschinen.at
SAFETY
26