Function And Operation; Installation Of The Hose - Conductix-Wampfler 040450-06x12 Instructions D'utilisation

Operating Instructions
Hose Reel
040450-...
3

Function and operation

•
The automatic hose reels of the series 040450-... can be fixed on the wall or on the ceiling. You can install the reel:
- pivoting on the wall : order the additional wall support 040450-10 or
- rotating on the ceiling : order the additional ceiling plate 0404450-11.
•
By means of the screw thread pin (Pos. 11) the hose guiding (Pos. 20 or 40) can be adjusted. Choose the adequate position
to generate only a minimal hose bending.
•
The coiling up of the hose reels is operated automatically by means of a spring.
Winding off the hose
•
Wind off the hose until the desired length.
The hose reel can be stopped at any click noise.
There are 16 possibilities for each rotation.
•
After stopping, it is possible to operate the hose non tension.
Coiling up of the hose
•
Draw the hose approx. ¼ turn forward (release the lock);
Now the hose is coiling up automatically.
Caution
For security reason and in order to avoid any injury and damages on the hose reel, the hose has to be guided manually
during the coiling up.
If required, the „lock" can be disconnected:
- stop the reel, with complete coiled up hose,
- release the counter nut (Pos. 70),
- hold the hose by hand, and
- turn in the grid bolt (screw thread pin with a slot) with a screw driver until the stop is
no longer operative ( hose is permanently live),
- tighten the counter nut (Pos. 70).
4

Installation of the hose

Installation of the hose (if the reel has been delivered without hose)
•
Adjust the drum manually to the limit stop, towards the shaft.
⎥ Refer to the red coloured label on the drum!
2-3 turns can be left, in order to allow a later tightening of the spring.
Caution
The drum is spring pressured: Never release!
Injury danger and spring damages risks!
•
Lock the drum to secure against resiling.
•
Connect the hose.
•
Draw the hose approx. ¼ turn forward (unlock) ;
The hose is now coiling up automatically.
BAL0400-0058b-D/E/F
www.conductix.com Seite 11 von 20