Publicité
Liens rapides
M
INI
MODEL EH-M3 ELECTRIC BOILER
Multi-stage electronic control with energy saving and other features.
EH-08-135-M3 through EH-20-135-M3, single phase, 3 wire, 120/208V, 120/240V
EH-12-345-M3 through EH-20-345-M3, three phase, 4 wire, 120/208V, 120/240V
OPERATION AND INSTALLATION INSTRUCTIONS
CONTENTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .PAGE
Description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2
Mounting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2
Piping . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2 & 4
Air Eliminator and Expansion Tanks . . . . . . . . . . . . . . . . . .2
Flow Switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2
Bypass . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2
Wiring (Warning: DO NOT turn on breakers on unit) . . . . . . . . .2
Wall Thermostat Flow Switch and Circulator . . . . . . . . . . .2
"Rough-In" Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
Service Connections and Electrical Ratings . . . . . . . . . . . .6
Electrical Connections & Sensor Locations . . . . . . . . . . . . . . . .5
Start-up . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
Fill System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
Air Elimination . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
Bypass Flow Adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . .7
Check for Proper Boiler and System Operation . . . . . . . . .7
Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
Periodic Inspection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
Control Setup . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8
Appendix A, B, C, & D . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9
Heating Contractor
Address
Phone Number
TRON
IMPORTANT:
This manual must be left with owner and should be hung
on or adjacent to the boiler for reference.
Model Number
Serial Number
Installation Date
Publication No. EH-M3-40 Rev. A • Printed in U.S.A. 1115
LISTED
89C4
Part No. 793860000
Publicité
Manuels Connexes pour Slant/Fin MiniTron EH M3 Serie
Sommaire des Matières pour Slant/Fin MiniTron EH M3 Serie
- Page 1 TRON MODEL EH-M3 ELECTRIC BOILER LISTED 89C4 Multi-stage electronic control with energy saving and other features. EH-08-135-M3 through EH-20-135-M3, single phase, 3 wire, 120/208V, 120/240V EH-12-345-M3 through EH-20-345-M3, three phase, 4 wire, 120/208V, 120/240V OPERATION AND INSTALLATION INSTRUCTIONS CONTENTS ........PAGE Description .
- Page 2 For cement walls, determine a tains a terminal board marked, (SLANT/FIN “INTERFACE location for the wall bracket to mount where the anchors will BOARD”).
- Page 3 Figure 1. Figure 1a. MINITRON "ROUGH-IN" DIMENSIONS STUDS 1. UNIT MAY BE FULLY ENCLOSED IF CLEARANCE DIMENSIONS ARE FACE TABS UP AND RESPECTED. FORWARD. INSTALL 2. DUAL DIMENSIONS ARE: INCH [MM] TABS LEVEL. 4 5/32 [105] ø 1 3/4 [44] 1 7/8 [48] (1/2"...
- Page 4 Figure 2. Typical SIngle Zone Piping Figure 3. Typical Multi-Zone Using 2-Way Valves Figure 4. Typical Multi-Zone Using 3-Way Valves NOTES: Optional blocking gate valve and hose end valve used (with drain valve) for fast fill and purge of system. IMPORTANT: Close bypass line valve (if used) during purging.
- Page 5 Mode 4 Outdoor Sensor Relay Factory Installed Boiler Outlet Sensor Boiler Inlet Sensor (Included) Boiler outlet sensor factory wired and Mode 5 installed in Outdoor cast iron heat Sensor exchanger Relay Factory Installed Boiler Figure 5. Electrical Connections Outlet Sensor Secondary Piping Sensor...
- Page 6 Table 1. Lug Sizes Grounding Lug Distribution Block Neutral Lug Wire Size Wire Size Wire Size Model Phase CU-AL† CU-AL† CU-AL† EH-8 thru 20 6-2/0 6-2/0 6-2/0 EH-12 thru 20 6-2/0 6-2/0 6-2/0 Neutral Lug Wire Size:For 3-wire single phase and 4-wire 3 phase models equipped with circuit breakers.
- Page 7 START-UP OPERATION - HOMEOWNER INFORMATION NOTE: Make sure that all circuit breakers ahead of and at the IMPORTANT: boiler are OFF. DO NOT operate boiler until the following criteria have been met: Fill System 1. Must be installed by qualified heating and electrical See Figures 2 through 4 for suggested purge valve and blocking contractors in accordance with instructions in this valve.
- Page 8 Basic Monitron II and Minitron M3 Setup Dual Temperatures are Fahrenheit (Celsius) Field Entry Example for Mode 4 or Mode 5 Low Temp Field Entry Baseboard System Note System Mode 4 or 5 4 or 5 4 = Parallel Piping, 5 = Primary/Secondary Piping STGMODE BOIL TARGET 180(82)
- Page 9 The boiler warrenty does not cover leaks resulting from corrosion caused by the use of underfloor plastic tubing without an oxygen diffusion barrier. Systems must have the non-oxygen diffusion barrier tubing separated from the boiler with a heat exchanger. Slant/Fin recommends the use of underfloor plastic tubing with an oxygen diffusion barrier.
- Page 10 SLANT/FIN CORPORATION, Greenvale, N.Y. 11548 • Phone: (516) 484-2600 FAX: (516) 484-5921 • Canada: Slant/Fin , Mississauga, Ontario LTD/LTEE www.slantfin.com...