Publicité
Les langues disponibles
Les langues disponibles
PREVENTATIVE MAINTENANCE
This is the safety alert symbol used for the PREVENTATIVE MAINTENANCE section of this manual to alert you to potential
personal injury hazards. Obey all instructions to avoid possible injury or death.
IMPORTANT: Any jack found to be defective as a result of worn parts due to lack of lubrication, or hydraulic system
contaminated with water, rust and/or foreign materials is not eligible for warranty consideration.
1.
Always store the jack in a well protected area where it will not be exposed to inclement weather, corrosive vapors, abrasive dust, or
any other harmful elements. The jack must be cleaned of water, snow, sand, grit, oil, grease or other foreign matter before using.
2.
The jack must be lubricated periodically in order to prevent premature wearing of parts. A general purpose grease must be applied to
the threads on the extension screw. Do not lubricate any portion of the lift saddle and make sure the saddle is free from grease, any
kind of lubricant, or debris before using the jack.
3.
It should not be necessary to
equipment. IMPORTANT: In order to prevent seal damage and jack failure, never use alcohol, hydraulic brake
in the jack. Use hydraulic jack oil.
4.
Every jack owner is responsible for keeping the jack label clean and readable. Use a mild soap solution to wash external surfaces of
the jack but not any moving hydraulic components.
5.
Do not attempt to make any hydraulic repairs unless you are a
TROUBLESHOOTING
PROBLEM: UNIT WILL NOT LIFT RATED LOAD.
ACTION: Purge air from hydraulic system by following procedure under SETUP.
PROBLEM: UNIT WILL NOT SUSTAIN RATED LOAD OR FEELS "SPONGY" UNDER RATED LOAD.
ACTION: Purge air from hydraulic system as above.
PROBLEM: UNIT WILL NOT LIFT TO FULL HEIGHT.
ACTION: Purge air from hydraulic system as above or check oil level in reservoir.
PROBLEM: UNIT STILL DOES NOT OPERATE.
ACTION: Contact your place of purchase for details on handling warranty.
WARRANTY HANDLING PROCEDURES & GUIDELINES
K-Tool International 1 Year Limited Warranty
K-Tool International Lifting Equipment is warranted to be free from defects in material and workmanship within one year from the date of
original purchase. This warranty is extended to the original retail purchaser only. If any jack or service-related item proves to be
defective during this period, it will be replaced or repaired, at K-Tool International's option, without charge. This warranty does not apply
to damage from accident, overload, misuse or abuse, nor does it apply to any equipment which has been altered or used with special
attachments other than those recommended. This warranty does not cover repairs made by anyone who is not a K-Tool International
Authorized Repair Center.
All Standard Duty jacks or service-related equipment will be replaced or repaired at K-Tool International's option during the 1 year
warranty period.
During the 1 year warranty period, all alleged defective products and/or parts must be shipped, freight prepaid, along
with proof of date-of-purchase, to K-Tool International Warranty Repair Center (contact information listed below).
your name, address and phone number along with proof-of-purchase information, and a brief description of the alleged defect. The
product will be returned to the customer, freight prepaid.
Many alleged defectives may simple be handled by calling K-Tool International Warranty Repair Center for parts.
In
no event shall K-Tool International be liable for incidental or consequential damages. The liability on any claim for loss or damage
arising out of the sale, resale or use of a jack or related service equipment, shall in no event exceed the purchase price. SOME STATES
DO NOT ALLOW THE EXCLUSION OR LIMITATION OF INCIDENTAL OR CONSEQUENTIAL DAMAGES, SO THE ABOVE LIMITATION
MAY NOT APPLY TO YOU.
THIS WARRANTY IS THE SOLE AND EXCLUSIVE WARRANTY PROVIDED IN CONNECTION WITH THE SALE OF K-TOOL
INTERNATIONAL PROFESSIONAL LIFTING EQUIPMENT. ALL OTHER WARRANTIES, INCLUDING ANY IMPLIED WARRANTIES OF
MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE, ARE EXCLUDED. THIS WARRANTY GIVES YOU SPECIFIC LEGAL
RIGHTS AND YOU MAY ALSO HAVE OTHER RIGHTS WHICH VARY FROM STATE TO STATE.
or top off the reservoir with hydraulic
31111 Old Wixom Road
Wixom, Michigan 48393
Ph.800.762.6002
unless there is an external leak. An external leak requires
hydraulic repair person that is familiar with this equipment.
FOR
KTI S
4
or transmission oil
TANDARD DUTY SERIES
Be certain to include
Nov 2016
Publicité
