Table des Matières
Publicité
Les langues disponibles
Les langues disponibles
Liens rapides
EXTERIOR HEAT
TRANSFER KIT
#HTK-EXT
For use with models #ALP-36S, #BHM-52,
#CLW-40, #CLW-50, #CLW-72, & #SFD-36
English and French installation manuals are available through your
local dealer. Visit our website www.kozyheat.com.
Les manuels d'installation en français et en anglais sont disponibles
chez votre détaillant local. Visitez www.kozyheat.com .
TABLE OF CONTENTS
1.0 INTRODUCTION .......................................................................3
1.1 Introduction ......................................................................................... 3
1.2 Approvals .............................................................................................. 3
1.3 Installation ............................................................................................ 3
1.4 Replacement Parts ............................................................................. 4
2.0 INSTALLATION .........................................................................5
2.2 Termination Cap Framing................................................................ 5
2.1 Rooftop Termination ......................................................................... 5
2.3 Horizontal Termination Cap Clearances .................................... 6
2.4 Installation Instructions ................................................................... 7
3.0 ELECTRICAL REQUIREMENTS ..............................................11
3.1 Electrical Requirements ................................................................11
3.2 Electrical Installation .......................................................................11
Hussong Manufacturing Co., Inc.
P.O. Box 577, 204 Industrial Park Drive
Lakefield, MN 56150-0577, USA
INSTALLER: Leave this manual with the appliance.
CONSUMER: Retain this manual for future reference.
HUSSONG MANUFACTURING CO., INC.
READ ALL THESE STEPS
BEFORE STARTING INSTALLATION.
LEAVE THESE INSTRUCTIONS WITH THE
APPLIANCE.
This kit must be installed by a qualified installer,
service agency, or gas supplier at the time of
the heater installation. These instructions must
be used in conjunction with the installation and
operation manual provided with the appliance.
Please read the appliance owner's manual
completely before performing any procedures in
these instructions.
Heat Transfer Kit - Exterior #HTK-EXT
Rev. 5, 5/20
Publicité
Chapitres
Table des Matières
Sommaire des Matières pour Kozy Heat Fireplaces HTK-EXT 101
-
Page 1: Table Des Matières
EXTERIOR HEAT TRANSFER KIT #HTK-EXT HUSSONG MANUFACTURING CO., INC. For use with models #ALP-36S, #BHM-52, #CLW-40, #CLW-50, #CLW-72, & #SFD-36 INSTALLER: Leave this manual with the appliance. CONSUMER: Retain this manual for future reference. English and French installation manuals are available through your local dealer. -
Page 3: Introduction
- exterior in accordance with manufacturer's instructions will result in conditions which may produce bodily injury and/or property damage. Figure 1.1, Possible Air Duct Locations/Terminations Heat Transfer Kit - Exterior #HTK-EXT R.5 Hussong Mfg. Co., Inc. • Kozy Heat Fireplaces... -
Page 4: Replacement Parts
HTK-EXT-109 HTK 6" Collar HTK-EXT-110 HTK-EXT-101 HTK-EXT-102 HTK-EXT-103 HTK-EXT-104 HTK-EXT-105 HTK-EXT-106 HTK-EXT-107 HTK-EXT-108 HTK 6” COLLAR #HTK-EXT-110 HTK-EXT-109 HTK-EXT-110 HTK AIR CHUTE (required for #HTK-EXT) Hussong Mfg. Co., Inc. • Kozy Heat Fireplaces Heat Transfer Kit - Exterior #HTK-EXT R.5... -
Page 5: Installation
Find the desired location of exterior heat transfer kit termination. For horizontal termination cap clearances, see Figure 2.3. 10” (254mm) 12” (305mm) ½ ” (343mm) Figure 2.1, Framing Dimensions Figure 2.2, Rooftop Enclosure Framing Heat Transfer Kit - Exterior #HTK-EXT R.5 Hussong Mfg. Co., Inc. • Kozy Heat Fireplaces... -
Page 6: Horizontal Termination Cap Clearances
VINYL SOFFIT, VINYL CEILING, AND VINYL OVERHANG DISCLAIMER: Clearances to heat resistant material (i.e. wood, metal). This does not include vinyl. Hussong Manufacturing Co., Inc. will not be held responsible for heat damage caused from terminating under vinyl overhangs, vinyl ceilings, or vinyl ventilated/unventi- lated soffits. Hussong Mfg. Co., Inc. • Kozy Heat Fireplaces Heat Transfer Kit - Exterior #HTK-EXT R.5... -
Page 7: Installation Instructions
300°F continuous exposure rating) to the #HTK-FEK around the entire metal flange where it would make contact with the #HTK- EXT. Figure 2.4, Remove Cover Assembly Heat Transfer Kit - Exterior #HTK-EXT R.5 Hussong Mfg. Co., Inc. • Kozy Heat Fireplaces... - Page 8 Instructions continue on page 10. Assembled #HTK-EXT-FEK Figure 2.7, Silicone Perimeter #HTK-EXT-FEK level and installed on wall Figure 2.8, Silicone Rear Figure 2.5, FEK Installed on Wall Hussong Mfg. Co., Inc. • Kozy Heat Fireplaces Heat Transfer Kit - Exterior #HTK-EXT R.5...
- Page 9 CLW-72 AIR CHUTE & DAMPER SHOWN FOR REFERENCE ONLY. YOUR AIR CHUTE AND DAMPER MAY LOOK DIFFERENT THAN ONE SHOWN. Figure 2.11, Air Chute Installation Figure 2.9, HTK-EXT FEK Install Heat Transfer Kit - Exterior #HTK-EXT R.5 Hussong Mfg. Co., Inc. • Kozy Heat Fireplaces...
- Page 10 17. Use (3) provided screws to attach the vinyl siding shield. See Figure 2.15. Figure 2.14, Liner Installed with Band Clamp Figure 2.12, Band Clamp Figure 2.15, Vinyl Siding Installed Figure 2.13, Screws in Inner Liner Hussong Mfg. Co., Inc. • Kozy Heat Fireplaces Heat Transfer Kit - Exterior #HTK-EXT R.5...
-
Page 11: Electrical Requirements
The provided on/off fan speed control switch is the only leads to attach to the wiring ran from the power source. BLACK WHITE GROUND Figure 3.1, HTK-EXT Wiring Diagram Heat Transfer Kit - Exterior #HTK-EXT R.5 Hussong Mfg. Co., Inc. • Kozy Heat Fireplaces... -
Page 13: Kit De Transfert De Chaleur Extérieur Nº Htk-Ext
KIT DE TRANSFERT DE CHALEUR EXTÉRIEUR nº HTK-EXT HUSSONG MANUFACTURING CO., INC. Pour utilisation avec modèles ALP-36S, BHM-52, CLW-40, CLW-50, CLW-72 et SFD-36 INSTALLATEUR : Laissez ce manuel avec l’appareil. PROPRIÉTAIRE : Conservez ce manuel pour le consulter. English and French installation manuals are available through your local dealer. -
Page 15: Introduction
Figure 1.1, Emplacements possibles des conduits d'air et des chapeaux d'évacuation Kit de transfert de chaleur extérieur HTK-EXT R.5 Hussong Mfg. Co., Inc. • Kozy Heat Fireplaces... -
Page 16: Pièces De Rechange
Raccord 6 po du HTK HTK-EXT-110 HTK-EXT-101 HTK-EXT-102 HTK-EXT-103 HTK-EXT-104 HTK-EXT-105 HTK-EXT-106 HTK-EXT-107 HTK-EXT-108 RACCORD 6 po HTK #HTK-EXT-110 HTK-EXT-109 HTK-EXT-110 CHUTE D’AIR DU HTK (requise pour HTK-EXT) Hussong Mfg. Co., Inc. • Kozy Heat Fireplaces Kit de transfert de chaleur extérieur HTK-EXT R.5... -
Page 17: Installation
Figure 2.3. 10” (254mm) ½ ” (343mm) 12” (305mm) Figure 2.1, Dimensions d'encadrement Figure 2.2, Encadrement de l'enceinte au toit Kit de transfert de chaleur extérieur HTK-EXT R.5 Hussong Mfg. Co., Inc. • Kozy Heat Fireplaces... -
Page 18: Dégagements Du Chapeau D'évacuation Horizontal
Ceci n'inclut pas le vinyle. Hussong Manufacturing Co., Inc. pas responsable des dommages dus à la chaleur si la terminaison (conduit) d'évacuation aboutit sous un avant-toit (ex. corniche) en vinyle, un plafond en vinyle ou un soffite (ventilé ou non ventilé) en vinyle Hussong Mfg. Co., Inc. • Kozy Heat Fireplaces Kit de transfert de chaleur extérieur HTK-EXT R.5... -
Page 19: Instructions D'installation
300°F en exposition continue) au HTK-FEK sur tout le pourtour de la bride en métal, aux points de contact avec le HTK-EXT. Figure 2.4, Retirez le couvercle Kit de transfert de chaleur extérieur HTK-EXT R.5 Hussong Mfg. Co., Inc. • Kozy Heat Fireplaces... - Page 20 Figure 2.7, Appliquez le scellant silicone tout autour (en périphérie) Figure 2.8, Appliquez le scellant silicone sur la face arrière Figure 2.5, FEK installé au mur Hussong Mfg. Co., Inc. • Kozy Heat Fireplaces Kit de transfert de chaleur extérieur HTK-EXT R.5...
- Page 21 REGISTRE PEUVENT DIFFÉRER DE CEUX ILLUSTRÉS Figure 2.11, Installation de la chute d'air Figure 2.9, Installation du kit d'extensions de finition FEK du HTK-EXT Kit de transfert de chaleur extérieur HTK-EXT R.5 Hussong Mfg. Co., Inc. • Kozy Heat Fireplaces...
- Page 22 Figure 2.14, Revêtement installé avec collier de serrage Figure 2.12, Collier de serrage Figure 2.15, Revêtement de vinyle installé Figure 2.13, Vis dans le revêtement intérieur Hussong Mfg. Co., Inc. • Kozy Heat Fireplaces Kit de transfert de chaleur extérieur HTK-EXT R.5...
-
Page 23: Installation Électrique
Si vous choisissez de ne pas utiliser le contrôle NOIR BLANC FIL DE TERRE Figure 3.1, Schéma de câblage du HTK-EXT Kit de transfert de chaleur extérieur HTK-EXT R.5 Hussong Mfg. Co., Inc. • Kozy Heat Fireplaces...