Scope Of Use; Safety Instructions - Rothenberger Industrial ROMAXI 030954E Mode D'emploi

030954-61_UniversalAnleitung_26 Sprachen.qxd:PRINT

Scope of Use

This high-performance burner is ideal for warming, burning off, shrinking, asphalt work, roofing, drying
concrete, as well as for chemical-free weed and moss killing. Use of the appliance for any other purpose
or modifications to the appliance count as misuse and can be extremely dangerous.
The appliance may only be used with propane or a propane/butane mix and with a suitable constant
pressure regulator. Use only refillable LPG cylinders. It can be dangerous to connect the burner to
other types of gas cylinder.
Commercial users must use a hose failure safety device while using this appliance. This is also recommended
for domestic users. The hose failure safety device can be obtained from the manufacturer as Art. No. 035925E.

SAFETY INSTRUCTIONS

Measures to be taken before connecting the gas cylinder
- Use only the gas containers and burner components described in this manual.
- The use of gas containers and/or burner components other than those described can be dangerous.
- Use only approved replacement parts.
- Never connect a gas cylinder to the device without first reading the instructions printed on it.
- Check that seal between the regulator and the gas container are in place and in good condition before connecting to
the gas container.
- Do not use the appliance if it has damaged or worn seals. Do not use an appliance which is leaking, damaged or which
does not operate properly.
- Check the hoses for damage.
- Never operate the device if any part is damaged.
- Connect or change the gas cylinder in a well ventilated location, preferably outside, away from any sources of ignition,
such as naked flames, pilots, electric fires and away from other people.
- Shut the taps on the appliance before connecting the gas container.
- Make certain that all connections are air tight and ensure that the gas connection is air tight before you light the burner.
- Smoking while connecting the gas cylinder is prohibited. Observe the instructions on container replacement. The
assembly must always start from the gas container.
- Beware of heating of the gas cylinder, or burning of hoses. Replace accessories if necessary
Operating conditions
- Set the device up such that it cannot topple or fall over.
- To prevent the risk of liquefied gas escaping, the gas cylinder may only be used when it is standing upwards.
- The appliance may not be used underground.
- Do not use the appliance in the proximity of heat sources (radiators, oven, open fires etc.).
- Use the appliance only in well-ventilated spaces. Observe applicable national regulations:
- For the supply of combustion air
- To prevent the accumulation of dangerous amounts of un-burnt gas.
- Use the burner only well away from inflammable or oily materials
- Wear protective clothing free of grease.
- Ensure that no vapours are inhaled.
- Always close the burner component when you take a break from work.
- The appliance may not be left unattended during operation as gas can escape if the flame goes out. This is potentially
dangerous.
- Always store the appliance out of the reach of children and prevent children from gaining access to the appliance.
- An irregular flame can be produced for a short duration if a new gas cylinder is connected to a cold burner.
- To prevent the risk of burns, do not touch the burner after use, even if the appliance has only been in use for a short
while.
CAUTION! Accessible parts can be very hot. Keep children away from the appliance.
What to do in case of a leak
If there is a leak on your appliance (smell of gas or formation of bubbles during a leak test) take it ourside immediately
into a well ventilated flame free location where the leak may be detected and stopped. If you wish to check for leaks on
your appliance, do it outside. Do not try to detect leaks using a flame, use soapy water or a leak detection spray. Keep
the appliance under observation until all of the gas has escaped. Observe the device till the gas has escaped from it fully.
7
09.01.2018 15:04