Troubleshooting; Technical Specifications; Material Composition And Recyclability - HydraMaster HYDRAPORT 100SC Manuel D'instructions

REVISED DATE

TROUBLESHOOTING:

IF THIS OCCURS
NO SPRAY
PUMP DOES NOT RUN
LOW SUCTION
NO SUCTION
LOW HEAT
NO HEAT
TECHNICAL SPECIFICATIONS (as installed and tested on the unit)
Model
Model No.
Voltage/frequency
Rated Current
Protection Class (electrical)
Solution Tank Capacity
Recovery Tank Capacity
Total Weight
Type
Aluminum
Electrical / motors / engines - misc
Ferrous metals
Harnesses / cables
Liquids
Plastic - non-recyclable
Plastic - recyclable
Polyethylene
Rubber
7/2016
CHECK THIS
Solution tank is empty, or filter is plugged.
Clogged spray tip(s).
Pump not running or not primed.
Valve on wand not operating.
Solution hose not completely connected to hose or to machine.
This pump motor runs on AC voltage, so it should start running as soon as you turn on the switch. If the
pump motor does not start running, check the wiring to the switch and to the motor. Check the switch to
see if it is "open". Check voltage to the switch.
Debris is plugging cleaning tool or vacuum hose.
Drain hose cap is not completely closed.
Recovery tank lid is not seated or gasket is damaged.
Ball in the float is blocking air flow. Turn off the vacuum so the ball will drop down, or the recovery tank
is full and needs to be emptied.
No power to motor.
Test the switch.
Test the vacuum motor.
Spraying too long. Try spraying for 12-15 seconds, or about three strokes.
Heat exchanger needs to be flushed.
Wrong tool being used. Too much water passing through. Longer hose or larger diameter hose, than
standard.
Heat is not turned on. The green circuit indicator light must be on.
No power in the wall outlet - check to see if the breaker has tripped.
Call your distributor for additional help.
Hydraport 100SC Hydraport 100H
56384889 56384890
120 V / 60 Hz 120 V / 60 Hz
15 Amp 15 Amp
Clase 1 Clase 1
12.5 gal (47 L) 12.5 gal (47 L)
11.0 gal (42 L) 11.0 gal (42 L)
87 lbs. (39.4 kg) 87 lbs. (39.4 kg)

Material Composition and Recyclability

% of machine weight
100
1%
9%
11%
6%
0%
3%
6%
60%
4%
INSTRUCTIONS FOR USE
Hydraport 200H
56384891
120 V / 60 Hz
15 Amp
Clase 1
12.5 gal (47 L)
11.0 gal (42 L)
93 lbs. (42 kg)
% of machine weight
100H
9%
8%
11%
5%
0%
3%
5%
55%
4%
56042660 - HydraPort 100, 200, 400
Hydraport 400H
56384892
120 V / 60 Hz
15 Amp
Clase 1
12.5 gal (47 L)
11.0 gal (42 L)
110 lbs. (50 kg)
% of machine weight
% recyclable
400H
8%
22%
9%
4%
0%
2%
4%
47%
3%
ENGLISH
100%
29%
100%
80%
100%
0%
100%
92%
20%
A - 13