Description; Safety Guidelines; General Safety Information - Campbell Hausfeld HU3508 Serie Mode D'emploi

Operating Instructions and Parts Manual

Description

This residential oilless compressor is designed for do-it-
yourselfers with a variety of home and automotive jobs. These
compressors power spray guns, impact wrenches and other
tools. Compressed air from this unit will contain moisture.
Install a water filter or air dryer if application requires dry air.
Unpacking
After unpacking the unit, inspect carefully for any damage
that may have occurred during transit. Make sure to tighten
fittings, bolts, etc., before putting unit into service.

Safety Guidelines

This manual contains information that is very important
to know and understand. This information is provided for
SAFETY and to PREVENT EQUIPMENT PROBLEMS. To help
recognize this information, observe the following symbols.
Danger indicates an imminently hazardous
situation which, if not avoided, WILL result
in death or serious injury.
Warning indicates a potentially hazardous
situation which, if not avoided, COULD
result in death or serious injury.
Caution indicates a potentially hazardous
situation which, if not avoided, MAY result
in minor or moderate injury.
Notice indicates important information,
that if not followed, may cause damage
to equipment.
NOTE: Information that requires special attention.

General Safety Information

CALIFORNIA PROPOSITION 65
This product or its power cord may contain
chemicals known to the State of California
to cause cancer and birth defects or other reproductive harm.
Wash hands after handling.
You can create dust when you
cut, sand, drill or grind materials such as
wood, paint, metal, concrete, cement, or other masonry. This
Breathable Air Warning
This compressor / pump is NOT equipped and should
NOT be used "as is" to supply breathing quality air.
For any application of air for human consumption,
you must fit the air compressor / pump with suitable
in-line safety and alarm equipment. This additional
equipment is necessary to properly filter and purify
the air to meet minimal specifications for Grade D
breathing as described in Compressed Gas Association
Commodity Specification G 7.1, OSHA 29 CFR 1910.
134, and/or Canadian Standards Associations (CSA).
DISCLAIMER OF WARRANTIES
In the event the compressor is used for the purpose of
breathing air application and proper in-line safety and
alarm equipment is not simultaneously used, existing
warranties are void, and the Manufacturer disclaims
any liability whatsoever for any loss, personal injury
or damage.
www.campbellhausfeld.com
dust often contains chemicals known to cause cancer, birth
defects, or other reproductive harm. Wear protective gear.
GENERAL SAFETY
Since the air compressor and other components used (material
pump, spray guns, filters, lubricators, hoses, etc.) make up a
high pressure pumping system, the following safety
precautions must be observed at all times:
1. Read all manuals included with this product
carefully. Be thoroughly familiar with the
controls and the proper use of the equipment.
2. Follow all local electrical and safety codes as well as in
the United States, the National Electrical Codes (NEC) and
Occupational Safety and Health Act (OSHA).
3. Only persons well acquainted with these rules of safe
operation should be allowed to use the compressor.
4. Keep visitors away and NEVER allow children in
the work area.
5. Wear safety glasses and use hearing protection
when operating the unit.
6. Do not stand on or use the unit as a handhold.
7. Before each use, inspect compressed air system and
electrical components for signs of damage, deterioration,
weakness or leakage. Repair or replace defective items
before using.
8. Check all fasteners at frequent intervals for proper
tightness.
Motors, electrical equipment
and controls can cause electrical
arcs that will ignite a fl ammable gas or vapor.
Never operate or repair in or near a fl ammable gas or vapor.
Never store fl ammable liquids or gases in the vicinity of the
compressor.
Never operate compressor
without a beltguard. This unit
can start automatically without warning. Personal
injury or property damage could occur from contact
with moving parts.
9. Do not wear loose clothing or jewelry that will
get caught in the moving parts of the unit.
Compressor parts may be hot
even if the unit is stopped.
10. Keep fingers away from a running compressor; fast moving
and hot parts will cause injury and/or burns.
11. If the equipment should start to vibrate
abnormally, STOP the engine/motor and check
immediately for the cause. Vibration is generally
a warning of trouble.
12. To reduce fire hazard, keep engine/motor exterior free of
oil, solvent, or excessive grease.
An ASME code safety relief valve with
a setting no higher than the maximum
allowable working pressure (MAWP) MUST be installed in the
tank for this compressor. The ASME safety valve must have
2
MANUAL