Westin 21-1310 Consignes

AUTOMOTIVE PRODUCTS, INC.
PART NUMBERS
21-1310 / 21-1315 23-1310 / 23-1315
21-1320 / 21-1325 23-1320 / 23-1325
21-1330 / 21-1335 23-1330 / 23-1335
ITEM QUANTITY
1,2
3
4
5
6
7
8
9
10
11
1,2
3
4
5
6
7
8
9
10
11
1,2
3
4
5
6
7
8
9
10
11
1. Remove the contents from the box and check for damage. Verify all parts are present. Read and understand instructions before beginning.
2. Mounting points for the side bar brackets are located on the inside of the vehicles rocker panel. The area behind the front of the rear tire should have four holes and a rec-
tangular slot.
3. Install clip nuts into all rectangular slots as shown in figure 1. Some mounting locations will not have provisions for a clip nut.
4. Attach the front driver side mounting bracket with the slot for the side bar facing the front tire. Use two of the supplied M10 bolts along with flat washers, lock washers,
and nuts to attach to the bottom two holes loosely. Use one M10 bolt along with one lock washer to attach bracket to clip nut already installed. (FIGURE 2,3)
5. Repeat step 3 for remaining brackets, slot for rear bracket faces the rear tire. (FIGURE 3)
6. Attach the driver side bar using the supplied M12 bolts, washers, and lock washers to the mounting bracket slots as shown in figure 2.
7. Align side bar and then tighten all remaining hardware.
(It is recommended to occasionally re-check and tighten all hardware)
FINISH PROTECTION
Westin products have a high quality finish that must be cared for like any other exposed finish on the vehicle. Protect the finish with a non-abrasive automotive wax, (e.g. Pure
Carnauba) on a regular basis. The use of any soap, polish, or wax that contains an abrasive is detrimental. As the compounds scratch the finish and open it to corrosion.
Westin Automotive Products, Inc.
5200 N. Irwindale Ave. Ste 220
Irwindale, Ca 91706
7/6/2009
INSTRUCTIONS—INSTRUCCIONES—CONSIGNES
APPLICATION: 1999-2009 FORD SUPERDUTY (REGULAR CAB, SUPER-CAB, & SUPERCREW)
2 SIDE BAR ASSEMBLY (DRIVER & PASSENGER SIDE)
4
4
4
4
6
14
22
14
8
2
4
4
4
4
6
14
22
14
8
2
4
4
4
4
6
14
22
14
8
DESCRIPTION
MOUNTING BRACKETS
M12 X 50MM HEX HEAD BOLTS
M12 LOCK WASHERS
M12 FLAT WASHERS
M10 CLIP NUTS
M10 X 40MM HEX HEAD BOLTS
M10 FLAT WASHERS
M10 LOCK WASHERS
M10 HEX NUTS
TOME PARTIDO la BARRA ASAMBLEA
(CONDUCTOR & el LADO de PASAJERO)
CORCHETES CRECIENTES
CABEZA del MAL DE OJO CIERRA M12 X 50 MM
ARANDELAS de CERRADURA M12
ARANDELAS PLANAS M12
TUERCAS de CLIP M10
CABEZA del MAL DE OJO CIERRA M10 X 40 MM
ARANDELAS PLANAS M10
ARANDELAS de CERRADURA M10
TUERCAS de MAL DE OJO M10
ASSEMBLEE LATERALE DE BARRE
(LE CONDUCTEUR & LE COTE DE PASSAGER)
MONTER MET ENTRE PARENTHESES
M12 X 50 MM LA TETE DE SORT VERROUILLE
M12 RONDELLES FREIN
M12 RONDELLES PLATES
M10 NOIX DE TROMBONE
M10 X 40 MM LA TETE DE SORT VERROUILLE
M10 RONDELLES PLATES
M10 RONDELLES FREIN
M10 NOIX DE SORT
12/2/2009
19MM SOCKET
19MM WRENCH
17MM SOCKET
RATCHET
ENCHUFE de 19 MM
ARRANCAN 19 MM
ENCHUFE de 17 MM
TRINQUETE
19 MM LA DOUILLE
19 MM LA CLE PLATE
17 MM LA DOUILLE
ENCLIQUETAGE A
Thank You for choosing Westin products
For additional installation assistance please call
Customer Service (800)793-7846
75-0917_1
TOOLS
DENTS