Publicité
Liens rapides
AUTOMOTIVE PRODUCTS, INC.
BULL BAR ASSEMBLY
ENSAMBLE DE PARRILLA
DELANTERA CON TIRÓN
LA BULL BAR
32-1950
32-1955
32-1970
32-1975
ITEM
QTY
1
1
BULL BAR ASSEMBLY
2,3
2
BRACKET, PASSENGER (2) AND DRIVER (3) 1500
4,5
2
BRACKET, PASSENGER (4) AND DRIVER (5) 2500/3500
6
4
RUBBER BUMPER
7
2
PLASTIC PLUG
8
4
3/8-16 X 1.25" HEX HEAD BOLT
9
8
3/8" FLAT WASHER
10
4
3/8" LOCK WASHER
11
4
3/8-16 HEX NUT
12
6
M12-1.75 REVERSIBLE LOCK NUT
13
6
M12 FLAT WASHER
1
1
ENSAMBLE DE PARRILLA DELANTERA CON TIRÓN
2,3
2
SOPORTES
4,5
2
SOPORTES
6
4
PARACHOQUES DE HULE
7
2
TAPONES DE PLÁSTICO
8
4
PERNOS CON CABEZA HEXAGONAL DE 3/8-16 X 1,25"
9
8
ARANDELAS PLANAS DE 3/8"
10
4
ARANDELAS DE PRESIÓN DE 3/8"
11
4
TUERCAS HEXAGONALES DE 3/8-16
12
6
TUERCA REVERSIBLE A PRESIÓN M12-1,75
13
6
ARANDELAS PLANAS DE M12
1
1
LA BULL BAR
2,3
2
SUPPORT, CÔTÉ PASSAGER (2) ET CÔTÉ CONDUCTEUR (3) 1500
4,5
2
SUPPORT, CÔTÉ PASSAGER (4) ET CÔTÉ CONDUCTEUR (5) 2500/3500
6
4
PARE-CHOCS CAOUTCHOUC
7
2
BOUCHONS DE PLASTIQUE
8
4
BOULONS A TETE HEXAGONALE 3/8-16 X 1,25 PO
9
8
RONDELLES PLATES 3/8 PO
10
4
RONDELLES A FREIN 3/8 PO
11
4
ÉCROUS HEXAGONAUX 3/8-16
12
6
ECROU FREINE REVERSIBLE M12-1,75
13
6
RONDELLES PLATES M12
STEP 1.
Remove the contents from box and check for damage. Verify all parts are present. Read instructions completely
before beginning.
NOTE:
It may be necessary to remove/relocate front license plate and license plate bracket. It is not required, but
STEP 2.
strongly recommended. If local/state laws requires a license plate, license plate relocation kit 32-0055 is available.
SEE FIGURE 2 FOR 1500 SERIES AND FIGURE 3 FOR 2500/3500 SERIES
NOTE:
For 4500/5500 Series. Remove tow hooks by removing the front and rear bolts that go through the frame.
The tow hooks will not be reinstalled.
STEP 3.
Determine passenger and driver brackets and install as shown.
STEP 4.
Attach Bull Bar to brackets using 3/8" fasteners as shown. Leave loose.
Make sure Bull Bar and brackets are properly aligned and tighten all fasteners. Recommended torque values are 17
STEP 5.
Ft. Lbs. for 3/8" fasteners and 65 Ft. Lbs. for 12mm fasteners.
LIGHT INSTALLATION:
socket for correct size of nut supplied, insert through large clearance hole in bottom of cross tube. Thread nut and
washers on stud and tighten.
started.
INSTRUCTIONS-INSTRUCCIONES-CONSIGNES
APPLICATION: 2006-07 DODGE RAM 1500/2500/3500
APLICACIÓN: DODGE RAM 1500/2500/3500, MOD. 2006-07
APPLICATION: DODGE RAM 1500/2500/3500 2006-07
CONTENTS -
CONTENIDO
, LADO DEL ACOMPAÑANTE
, LADO DEL ACOMPAÑANTE
NOTE: Westin advises the installer to use a thread lubricant on all of the stainless steel fasteners.
Insert threaded stud on base of the light through hole in cross tube. Using a ratchet, extension and
SEE FIGURE 1. NOTE:
2008 DODGE RAM 4500/5500
DODGE RAM 4500/5500, MOD. 2008
DODGE RAM 4500/5500 2008
- CONTENU
(2)
Y EL CONDUCTOR
(3) 1500
(4)
Y EL CONDUCTOR
(5) 2500/3500
A short socket, not a deep well works best to get the nut
WO:
2
1
3
TOOLS -
HERRAMIENTA
9/16" SOCKET
9/16" WRENCH
19MM SOCKET
18MM SOCKET
RATCHET
TORQUE WRENCH
DADO DE 9/16"
LLAVE DE TUERCAS DE 9/16"
DADO DE 19MM
DADO DE 18MM
MANERAL
LLAVE DE TORQUE
DOUILLE 9/16 PO
CLE 9/16 PO
DOUILLE 19MM
DOUILLE 18MM
CLIQUET
CLE DE COUPLE
SEE FIGURE 4.
75-0608 REVISION D 4/23/08
4
5
- OUTILS
Publicité
Manuels Connexes pour Westin 32-1950
Sommaire des Matières pour Westin 32-1950
- Page 1 RONDELLES PLATES M12 STEP 1. Remove the contents from box and check for damage. Verify all parts are present. Read instructions completely NOTE: Westin advises the installer to use a thread lubricant on all of the stainless steel fasteners. before beginning. NOTE: It may be necessary to remove/relocate front license plate and license plate bracket.
- Page 2 FINISH PROTECTION Westin products have a high quality finish that must be cared for like any other exposed finish on the vehicle. Protect the finish with a non-abrasive automotive wax, (e.g. Pure Carnauba) on a regular basis. The use of any soap, polish or wax that contains an abrasive is detrimental, as the compounds scratch the finish and open it to corrosion.
- Page 3 LIGHT FARO PHARE CROSS TUBE THREADED STUD TUBO TRANSVERSA BIRLO ROSCADO TUBE TRANSVERSALL BOULON FILETE FASTENERS SUPPLIED WITH LIGHTS SUJETADORES PROVISTOS CON LOS FAROS ATTACHES FOURNIES AVES LES PHARES CLEARANCE HOLE AGUJERO ESPACEMENT FIGURE 1 LIGHT ATTACHMENT (LIGHTS NOT INCLUDED) FIGURA 1 ACCESORIO PARA FARO (NO SE INCLUYEN LOS FAROS) FIGURE 1...
- Page 4 DANS LA JUPE AVANT. FIGURE 4 FIGURE 4 FIGURA 4 FIGURA 4 Thank You for choosing Westin products Westin Automotive Products, Inc. For additional installation assistance please call 5200 N. Irwindale Ave. Suite 220 Irwindale, Ca. 91706 Customer service (800) 793-7846 or (507) 375-3559...